Opel Frontera UE. Manual - part 927

6E2–94

6VD1 3.2L ENGINE DRIVEABILITY AND EMISSIONS

Evaporative (EVAP) Emissions Canister Purge Valve Check

  (Cont'd)

Step

No

Yes

Value(s)

Action

9

1. Disconnect the solenoid electrical connector.
2. Connect a test lamp between the harness

terminals.

Does the test lamp light?

—

Go to 

Step 7

Go to 

Step 10

10

Probe terminal A and terminal B with a test lamp to
ground.

Does the test lamp light on both terminals?

—

Go to 

Step 11

Go to 

Step 12

11

Repair the short to voltage in the RED/BLUE wire.

Is the action complete?

—

Verify repair

—

12

Does on of the terminals light the test lamp?

—

Go to 

Step 13

Go to 

Step 14

13

Check for an open in the RED/BLU wire between the
purge solenoid and the PCM.

Was there an open circuit?

—

Go to 

Step 15

Go to 

Step 6

14

Repair the open in the BLK/YEL wire.

Is the action complete?

—

Verify repair

—

15

Repair the open in the RED/BLU wire.

Is the action complete?

—

Verify repair

—

6E2–95

6VD1 3.2L ENGINE DRIVEABILITY AND EMISSIONS

PCM Diagnostic Trouble Codes

The following table lists the diagnostic trouble codes
supported by this vehicle application.If any DTCs not
listed here are displayed by a Tech 2, the Tech 2 data may
be faulty; notify the Tech 2 manufacturer of any DTCs
displayed that are not included in the following table.
PCM Diagnostic Trouble Codes

DTC

Description

Type

Illuminate MIL

P0101

MAF System Performance

B

Yes

P0102

MAF Sensor Circuit  Low Frequency

A

Yes

P0103

MAF Sensor Circuit  High Frequency

A

Yes

P0107

MAP Sensor Circuit  Low Voltage

A

Yes

P0108

MAP Sensor Circuit High Voltage

A

Yes

P0112

IAT Sensor Circuit  Low Voltage

A

Yes

P0113

IAT Sensor Circuit  High Voltage

A

Yes

P0117

ECT Sensor Circuit  Low Voltage

A

Yes

P0118

ECT Sensor Circuit  High Voltage

A

Yes

P0121

TP System Performance

A

Yes

P0122

TP Sensor Circuit  Low Voltage

A

Yes

P0123

TP Sensor Circuit  High Voltage

A

Yes

P0131

HO2S Circuit  Low Voltage Bank 1 Sensor  1

A

Yes

P0132

HO2S Circuit  High Voltage Bank 1 Sensor  1

A

Yes

P0134

HO2S Circuit  Insufficient Activity Bank 1 Sensor  1

A

Yes

P0151

HO2S Circuit  Low Voltage Bank  2 Sensor 1

A

Yes

P0152

HO2S Circuit  High Voltage Bank  2 Sensor 1

A

Yes

P0154

HO2S Circuit  Insufficient Activity Bank 2 Sensor 1

A

Yes

P0171

Fuel Trim System Lean Bank 1

B

Yes

P0172

Fuel Trim System Rich Bank 1

B

Yes

P0174

Fuel Trim System Lean Bank 2

B

Yes

P0175

Fuel Trim System Rich Bank 2

B

Yes

P0201

Injector 1 Control Circuit

A

Yes

P0202

Injector 2 Control Circuit

A

Yes

P0203

Injector 3 Control Circuit

A

Yes

P0204

Injector 4 Control Circuit

A

Yes

P0205

Injector 5 Control Circuit

A

Yes

P0206

Injector 6 Control Circuit

A

Yes

P0325

KS Module Circuit

B

No

P0327

KS Sensor Circuit

B

No

P0336

58X Reference Signal Circuit

B

Yes

P0337

CKP Sensor Circuit Low Frequency

B

Yes

P0341

CMP Sensor Circuit Performance

B

Yes

P0342

CMP Sensor Circuit Low

B

Yes

P0351

Ignition 1 Control Circuit

A

Yes

P0352

Ignition 2 Control Circuit

A

Yes

P0353

Ignition 3 Control Circuit

A

Yes

6E2–96

6VD1 3.2L ENGINE DRIVEABILITY AND EMISSIONS

P0354

Ignition 4 Control Circuit

A

Yes

P0355

Ignition 5 Control Circuit

A

Yes

P0356

Ignition 6 Control Circuit

A

Yes

P0404

EGR Open Stuck

B

Yes

P0405

EGR Lo Volt

A

Yes

P0406

EGR Hi Voltage

A

Yes

P0502

VSS Circuit  Low Input

B

Yes

P0562

System Voltage Low

D

No

P0563

System Voltage High

D

No

P0601

PCM Memory

A

Yes

P0705

Transmisson Rang Sensor Illegal Position  (Refer to 

4L30-E Automatic

Transmission)

D

No

P0706

Transmisson Range Sensor Performance (Refer to 

4L30-E Automatic

Transmission)

D

No

P0712

Transmission Fluid Temperature (TFT) Low Voltage (Refer to 

4L30-E

Automatic Transmission Diagnosis)

D

No

P0713

Transmission Fluid Temperature (TFT) High Voltage (Refer to 

4L30-E

Automatic Transmission Diagnosis)

D

No

P0719

Brake Switch Circuit Low (

Refer to 4L30-E Automatic Transmission

Diagnosis)

D

No

P0722

Output Speed Sensor Circuit No Signal (Refer to 

4L30-E Automatic

Transmission)

A

Yes

P0723

Output Speed Sensor Circuit Intermittent Signal (Refer to 

4L30-E

Automatic Transmission)

A

Yes

P0730

Incorrect Gear Ratio (Refer to 

4L30-E Automatic Transmission)

C

No

P0748

Transmission Pressure Control Solenoid (PCS) – Electrical Circuit Fault
(Refer to 

4L30-E Automatic Transmission Diagnosis)

C

No

P0753

Transmission Shift Solenoid “A” – Electrical Circuit Fault (Refer to 

4L30-E

Automatic Transmission Diagnosis)

A

Yes

P0758

Transmission Shift Solenoid “B” – Electrical Circuit Fault (Refer to 

4L30-E

Automatic Transmission Diagnosis)

A

Yes

P1171

Fuel System Lean During Acceleration

A

Yes

P1380

ABS Rough Road ABS System Fault

D

Yes

P1381

ABS Rough Class 2 Serial Link Error

D

Yes

P1404

EGR Closed Stuck

D

Yes

P1508

IAC System Low RPM

B

Yes

P1509

IAC System High RPM

B

Yes

P1618

Serial Peripheral Interface (SPI) PCM Interprocessor Communication
Error (Automatic Transmission Only)

A

Yes

P1625

PCM Unexpected Reset

A

Yes

P1640

Driver-1-Input High Voltage

D

No

P1790

TRANS ROM Checksum Error (Refer to 

4L30-E Automatic Transmission

Diagnosis)

A

Yes

P1792

TRANS EEPROM Checksum Error (Refer to 

4L30-E Automatic

Transmission Diagnosis)

A

Yes

P1835

TRANS Kick Down Switch Malfunction (Refer to 

4L30-E Automatic

Transmission Diagnosis)

D

No

6E2–97

6VD1 3.2L ENGINE DRIVEABILITY AND EMISSIONS

P1850

Brake Band Apply Solenoid Manlfunction (Refer to 

4L30-E Automatic

Transmission Diagnosis)

D

No

P1860

TCC PWM Solenoid Circuit Fault (Refer to 

4L30-E Automatic

Transmission Diagnosis)

A

Yes