Volkswagen Golf / Golf GTI / Golf Variant. Manual - part 765

♦ Pressure Tester Kit - Adapter Set - Hose 3 - VAS6550/3-3-

♦ Pressure Regulator Valve - VAS6550/4-

♦ Engine and Gearbox Jack - VAS6931-

♦ Hose Clamps - Up To 25 mm - 3094-

♦ Multimeter, for example Analog/Digital Multimeter - FLU83III-
♦ Evaporative Emissions Tester - KLI9210-
♦ Evaporative Emissions Tester - Adapter 55 - KLI9210/55-1-
♦ Injection Rate Comparison Meter Kit - Remote Cable -

VAG1348/3A-

♦ Fuel Extractor Unit - VAS5190A- (without illustration) for E 85

- fuel type.

♦ Vehicle Diagnostic Tester - Test Adapter - 5 Pin - VAS5565-
♦ Pressure Tester Kit - Adapter Set - Hose 4 - VAS6550/3-4-
♦ Vehicle Diagnostic Tester

Revision History

DRUCK NUMBER: K0059240921

Fac‐

tory

Edi‐

tion

Edit

Edi‐

tion

Job

Type

Fee

dba

Notes

Quality

Checke

d By

01.2

016

02/2

4/20

Fac‐

tory

Up‐

date

N/A

Joe Y

08.2

015

11/2

5/20

Fac‐

tory

Up‐

date

N/A

Eric P.

05.2

015

10/0

8/20

Lo‐

cal

Feed

back

112

731

Change RON rating for

CXCB from 95 to 91 start‐

ing in 2016

Eric P.

05.2

015

8/14/

2015

Editorial Review - Added

MRP’s

Jim H

05.2

015

07/0

1/20

Lo‐

cal

Feed

back

109

570

Added steps to remove

suction hose at bottom of

the fuel delivery unit

Eric P.

05.2

015

06/2

6/20

Fac‐

tory

Up‐

date

N/A

Eric P.

02.2

015

05/2

7/20

Lo‐

cal

Feed

back

109

523

Added engine CXCB to

metadata per factory

Eric P.

02.2

015

02/2

4/20

Fac‐

tory

Up‐

date

N/A Added sales code BX5 to

metadata.

Eric P.

07.2

014

10/1

5/20

Laun

N/A

Eric P.

04.2

014

6/12/

2014

Fac‐

tory

Revi‐

sion

N/A

Joe Y.

01.2

014

4/02/

2014

Fac‐

tory

New

N/A

Joe Y.

Cautions & Warnings

Page 1 of 3

All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of
Volkswagen of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a
retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without
the prior expressed written permission of the publisher.

Version 1.0

Please read these WARNINGS and CAUTIONS before proceeding with maintenance
and repair work. You must answer that you have read and you understand these
WARNINGS and CAUTIONS before you will be allowed to view this information.

•= If you lack the skills, tools and equipment, or a suitable workshop for any procedure described in this manual, we

suggest you leave such repairs to an authorized Volkswagen retailer or other qualified shop. We especially urge
you to consult an authorized Volkswagen retailer before beginning repairs on any vehicle that may still be covered
wholly or in part by any of the extensive warranties issued by Volkswagen.

•= Disconnect the battery negative terminal (ground strap) whenever you work on the fuel system or the electrical

system. Do not smoke or work near heaters or other fire hazards. Keep an approved fire extinguisher handy.

•= Volkswagen is constantly improving its vehicles and sometimes these changes, both in parts and specifications,

are made applicable to earlier models. Therefore, part numbers listed in this manual are for reference only. Always
check with your authorized Volkswagen retailer parts department for the latest information.

•= Any time the battery has been disconnected on an automatic transmission vehicle, it will be necessary to

reestablish Transmission Control Module (TCM) basic settings using the VAG 1551 Scan Tool (ST).

•= Never work under a lifted vehicle unless it is solidly supported on stands designed for the purpose. Do not support

a vehicle on cinder blocks, hollow tiles or other props that may crumble under continuous load. Never work under a
vehicle that is supported solely by a jack. Never work under the vehicle while the engine is running.

•= For vehicles equipped with an anti-theft radio, be sure of the correct radio activation code before disconnecting the

battery or removing the radio. If the wrong code is entered when the power is restored, the radio may lock up and
become inoperable, even if the correct code is used in a later attempt.

•= If you are going to work under a vehicle on the ground, make sure that the ground is level. Block the wheels to

keep the vehicle from rolling. Disconnect the battery negative terminal (ground strap) to prevent others from
starting the vehicle while you are under it.

•= Do not attempt to work on your vehicle if you do not feel well. You increase the danger of injury to yourself and

others if you are tired, upset or have taken medicine or any other substances that may impair you or keep you from
being fully alert.

•= Never run the engine unless the work area is well ventilated. Carbon monoxide (CO) kills.

•= Always observe good workshop practices. Wear goggles when you operate machine tools or work with acid. Wear

goggles, gloves and other protective clothing whenever the job requires working with harmful substances.

•= Tie long hair behind your head. Do not wear a necktie, a scarf, loose clothing, or a necklace when you work near

machine tools or running engines. If your hair, clothing, or jewelry were to get caught in the machinery, severe
injury could result.

•= Do not re-use any fasteners that are worn or deformed in normal use. Some fasteners are designed to be used

only once and are unreliable and may fail if used a second time. This includes, but is not limited to, nuts, bolts,
washers, circlips and cotter pins. Always follow the recommendations in this manual - replace these fasteners with
new parts where indicated, and any other time it is deemed necessary by inspection.

Content .. 763 764 765 766 ..