Nissan Teana J32. Manual - part 1098

 

  Index      Nissan     Nissan Teana J32 (2008 year) - Service and Repair Manual

 

Search            

 

 

 

 

 

 

 

 

 

Content   ..  1096  1097  1098  1099   ..

 

 

Nissan Teana J32. Manual - part 1098

 

 

SRC-146

< SYMPTOM DIAGNOSIS >

SRS AIR BAG WARNING LAMP DOES NOT TURN ON

SRS AIR BAG WARNING LAMP DOES NOT TURN ON

Diagnosis Procedure

INFOID:0000000003814107

1.

CHECK METER FUSE

Check the meter fuse. Refer to 

PG-82, "Fuse"

.

Is 10A fuse [No.4, located in fuse block (J/B)] normal?

YES

>> GO TO 3.

NO

>> Replace the fuse GO TO 2.

2.

CHECK METER FUSE AGAIN

Turn ignition switch ON.
Check the meter fuse. Refer to 

PG-82, "Fuse"

.

Did the meter fuse blow again?

YES

>> Repair or replace the related harness.

NO

>> INSPECTION END

3.

CHECK HARNESS CONNECTION

1.

Check harness connection between air bag diagnosis sensor unit and combination meter.

2.

Disconnect air bag diagnosis sensor unit connector and turn ignition switch ON.

Did air bag warning lamp turn ON?

YES

>> Replace air bag diagnosis sensor unit. Refer to 

SR-22, "Exploded View"

.

NO

>> Replace combination meter assembly. Refer to 

MWI-127, "Exploded View"

.

PRECAUTIONS

SRC-147

< PRECAUTION >

C

D

E

F

G

I

J

K

L

M

A

B

SRC

N

O

P

PRECAUTION

PRECAUTIONS

Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT 
PRE-TENSIONER"

INFOID:0000000003814141

The Supplemental Restraint System such as “AIR BAG” and “SEAT BELT PRE-TENSIONER”, used along
with a front seat belt, helps to reduce the risk or severity of injury to the driver and front passenger for certain
types of collision. Information necessary to service the system safely is included in the “SRS AIRBAG” and
“SEAT BELT” of this Service Manual.

WARNING:

• To avoid rendering the SRS inoperative, which could increase the risk of personal injury or death in

the event of a collision which would result in air bag inflation, all maintenance must be performed by
an authorized NISSAN/INFINITI dealer.

• Improper maintenance, including incorrect removal and installation of the SRS, can lead to personal

injury caused by unintentional activation of the system. For removal of Spiral Cable and Air Bag
Module, see the “SRS AIRBAG”.

• Never use electrical test equipment on any circuit related to the SRS unless instructed to in this Ser-

vice Manual. SRS wiring harnesses can be identified by yellow and/or orange harnesses or harness
connectors.

Service

INFOID:0000000003814109

• Do not use electrical test equipment to check SRS circuits unless instructed to in this Service Manual.
• Before servicing the SRS, turn ignition switch OFF, disconnect battery negative terminal and wait at least 3

minutes.
For approximately 3 minutes after the battery negative terminal is removed, it is still possible for the air bag
and seat belt pre-tensioner to deploy. Therefore, do not work on any SRS connectors or wires until at least 3
minutes have elapsed.

• Diagnosis sensor unit must always be installed with their arrow marks “

” pointing towards the front of the

vehicle for proper operation. Also check diagnosis sensor unit for cracks, deformities or rust before installa-
tion and replace as required.

• The spiral cable must be aligned in the neutral position since its rotations are limited. Do not turn steering

wheel and column after removal of steering gear.

• Handle air bag module carefully. Always place driver and front passenger air bag modules with the pad side

facing upward and seat mounted front side air bag module standing with the stud bolt side facing down.

• Conduct self-diagnosis to check entire SRS for proper function after replacing any components.
• After air bag inflates, the front instrument panel assembly should be replaced if damaged.
• Always replace instrument panel pad following front passenger air bag deployment.

ST-1

STEERING

C

D

E

F

H

I

J

K

L

M

SECTION 

ST

A

B

ST

N

O

P

CONTENTS

STEERING SYSTEM

SYMPTOM DIAGNOSIS  ...............................

2

NOISE, VIBRATION AND HARSHNESS 
(NVH) TROUBLESHOOTING  .............................

2

NVH Troubleshooting Chart  ......................................

2

PRECAUTION ...............................................

3

PRECAUTIONS ...................................................

3

Precaution for Supplemental Restraint System 
(SRS) "AIR BAG" and "SEAT BELT PRE-TEN-
SIONER" .................................................................
..

3

Precaution Necessary for Steering Wheel Rota-
tion after Battery Disconnect  ...................................
..

3

Service Notice or Precautions for Steering System 

......

3

PREPARATION ............................................

5

PREPARATION ...................................................

5

Special Service Tools ................................................

5

ON-VEHICLE MAINTENANCE .....................

7

POWER STEERING FLUID  ................................

7

Inspection ..................................................................

7

STEERING WHEEL .............................................

9

Inspection ..................................................................

9

ON-VEHICLE REPAIR .................................

12

STEERING WHEEL ............................................

12

Exploded View  ........................................................

12

Removal and Installation .........................................

12

STEERING COLUMN  .........................................

13

Exploded View  ........................................................

13

Removal and Installation .........................................

13

Inspection ................................................................

14

LOWER SHAFT  ................................................

16

Exploded View .........................................................

16

Removal and Installation  .........................................

16

Inspection ................................................................

17

STEERING GEAR AND LINKAGE  ...................

18

Exploded View .........................................................

18

Removal and Installation  .........................................

19

Disassembly and Assembly .....................................

20

Inspection ................................................................

26

POWER STEERING OIL PUMP  .......................

28

Exploded View .........................................................

28

Removal and Installation  .........................................

29

Disassembly and Assembly .....................................

29

Inspection ................................................................

32

HYDRAULIC LINE  ............................................

34

Exploded View .........................................................

34

Removal and Installation  .........................................

35

SERVICE DATA AND SPECIFICATIONS 
(SDS) ............................................................

37

SERVICE DATA AND SPECIFICATIONS 
(SDS) .................................................................

37

General Specifications .............................................

37

Steering Wheel Axial End Play and Play .................

37

Steering Wheel Turning Force .................................

37

Steering Angle  .........................................................

37

Steering Column Length ..........................................

37

Steering Column Mounting Dimensions  ..................

37

Steering Column Operating Range  .........................

37

Lower Shaft Sliding Range  ......................................

38

Rack Sliding Force  ..................................................

38

Rack Stroke  .............................................................

38

Socket Swing Force and Rotating Torque ...............

38

Socket Axial End Play  .............................................

38

Inner Socket Length  ................................................

38

Relief Oil Pressure ...................................................

38

ST-2

< SYMPTOM DIAGNOSIS >

NOISE, VIBRATION AND HARSHNESS (NVH) TROUBLESHOOTING

SYMPTOM DIAGNOSIS

NOISE, VIBRATION AND HARSHNESS (NVH) TROUBLESHOOTING

NVH Troubleshooting Chart

INFOID:0000000003806305

Use the chart below to find the cause of the symptom. If necessary, repair or replace these parts.

×

: Applicable

Reference

ST

-7, "

Inspe

c

ti

on

"

ST

-7, "

Inspe

c

ti

on

"

ST

-26,

 "

In

sp

ectio

n

"

ST

-26,

 "

In

sp

ectio

n

"

ST

-26,

 "

In

sp

ectio

n

"

ST

-7, "

Inspe

c

ti

on

"

ST

-9, "

Inspe

c

ti

on

"

ST

-9, "

Inspe

c

ti

on

"

EM-12, "

Checking

"

ST

-9, "

Inspe

c

ti

on

"

ST

-18,

 "

Ex

pl

od

ed V

iew

"

 

ST

-14,

 "

In

sp

ectio

n

"

 

ST

-13,

 "

Ex

pl

od

ed V

iew

"

ST

-18,

 "

Ex

pl

od

ed V

iew

"

NVH in DLN 

section.

NVH in DLN 

section.

NVH in F

AX, RAX

, FSU, RSU section.

NVH in WT

 se

ct

io

n.

NVH in WT

 se

ct

io

n.

NVH in F

AX section.

NVH in BR section.

Possible cause and SUSPECTED PARTS

F

lui

d l

e

v

e

l

Air i

n

 h

y

drau

lic s

y

s

te

m

Oute

r/in

ne

r s

o

c

k

e

t b

a

ll jo

in

t s

w

ing

in

g

 t

o

rq

ue

Oute

r/in

ne

r socke

t b

a

ll jo

in

t ro

ta

ti

ng

 to

rqu

e

Oute

r/in

ne

r s

o

c

k

e

t b

a

ll jo

in

t e

n

d

 pl

ay

S

tee

rin

g

 f

lui

d l

e

a

k

a

g

e

S

te

e

ri

ng

 whe

e

pl

ay

S

te

e

ri

ng

 ge

ar ra

c

k

 s

lid

in

forc

e

Driv

e b

e

lt

 lo

os

en

es

s

Im

prop

er ste

e

ri

ng

 whe

e

l

Im

prop

er ins

ta

lla

ti

on or 

lo

o

s

e

n

e

s

s

 o

ti

lt loc

k

 le

ve

r

M

o

u

n

ti

ng

 lo

os

en

es

s

S

tee

rin

g

 c

o

lu

m

n

 d

e

fo

rm

at

io

n

 or da

ma

ge

Im

prop

er 

ins

ta

lla

ti

on 

or l

o

o

s

e

n

e

s

s

 o

f s

tee

rin

g

 c

o

lu

m

n

S

tee

rin

g

 l

in

ka

g

e

 lo

os

en

es

s

PROPELLER SHAF

T

DIFFERE

N

T

IAL

AXLE

 and 

SUSPENSION

TIRE

ROA

D

 WHEEL

DRIVE SHA

F

T

BRAKE

Symptom

Steering

Noise

× × × × × × × × ×

× ×

× × × × × × ×

Shake

×

×

×

× × × × ×

Vibration

×

× × ×

×

× ×

×

Shimmy

×

×

×

× × ×

×

Judder

×

×

× × ×

×

 

 

 

 

 

 

 

Content   ..  1096  1097  1098  1099   ..