Hyundai: Engine D4FA. Manual - part 137

 

  Index      Hyundai     Hyundai: Engine D4FA - service repair manual

 

Search            

 

 

 

 

 

 

 

 

 

Content   ..  135  136  137  138   ..

 

 

Hyundai: Engine D4FA. Manual - part 137

 

 

DIESEL CONTROL SYSTEM

FLA -419

SCHEMATIC DIAGRAM

E3124AAD

28

G142 terminal 4

ON/START Input

C101-2 ECM

C101-1 ECM

1

30 29

31

32

38

39

36

37

35

33

34

40

42 41

46 45 44 43

48 47

50 49

2

3

4

6

5

8

7

12 11 10 9

13

14

15

18 17

19

16

22

25

27 26

23

20

21

24

28

51

75 74
53 52

73

79 78 77 76

80

81

83 82

84

86 85

87

89 88

90

92 91

93

94

57

69 68

70

71

64

54

55

56

61

58

59

60

63 62

65

66

67

72

C101-1 ECM

C142 J/C

MAFS

Water in fuel sensor

I/P JUNTION BOX

2

I/P-E

4

28. ON/START Input

Hot in ON or START

11

10A ECU

[CIRCUIT DIAGRAM]

[HARNESS CONNECTOR]

[CONNECTOR INFORMATION]

Terminal

Terminal

Connected to

Connected to

Function

1

2

4

3

6

5

8 7

12

13

16

17

18

23 22

20

21

19

27 26 25 24

28

29

30

14

9

10

11

15

33 32 31

34

37

41

42

40 39 38

35

36

43

44

47 46

49 48

50

53

56

58 57

54

51

52

55

59

60
45

EGNG013E

SIGNAL WAVEFORM AND DATA

E713C46C

Main relay

IG KEY signal

Fig.1

Fig.1) The waveforms of  IG KEY "ON" signal and main relay operation are measured simultaneously. 
          Check poor connection at the point of IG KEY "ON". 

EGNG013F

TERMINAL AND CONNECTOR INSPECTION

EF17371E

1.

Electrical systems consist of a lot of harness and connectors, poor connection of terminals can cause various prob-
lems and damge of component.

2.

Perform checking procedure as follows.

1)

Check damage of harness and terminals : Check terminals for contact resistance, corrosion and deformation.

FLA -420

FUEL SYSTEM

2)

Check connecting condition of ECM and component connector : Check terminal seperation, damage of locking
device and connecting condition between terminal and wiring.

NOTE

Disconnect the pin which requires checking at male connector and insert it to the terminal at female connector for
checking connecting condition. ( after checking, reconnect the pin at correct position. )

3.

Is the problem found?

YES

▶ Repair the trouble causing part and go to "Verification of Vehicle Repair".

NO

▶ Go to "Signal Circuit Inspection".

SIGNAL CIRCUIT INSPECTION

E29AAC29

1.

IG KEY "OFF", ENGINE "OFF".

2.

Connect Oscilloscope to ECM connector terminal 28 with ECM connector being connected.

3.

Check IG KEY "ON" signal waveform at IG KEY "ON".

specification : The signals indicate poor connection should not exist at IG KEY "ON" range.

4.

Does abnormal waveform generate at IG KEY "ON" range?

YES

▶ Repair IG KEY S/W and poor connection of In-pannel junction box 10A ECU fuse, C142 joint connector terminal
2, 4 and related circuit and go to "Verification of Vehicle Repair".

NO

▶ Go to "Verification of Vehicle Repair".

※ Repeat this process 2~3 times.

VERIFICATION OF VEHICLE REPAIR

E1B6548E

After a repair, it is essential to verify that the fault is corrected.

1.

After connecting Scantool select "DIAGNOSTIC TROUBLE CODES(DTCs)" mode.

2.

Clear recorded DTC using Scantool.

3.

Drive the vehicle within DTC "Enable conditions" in "General information".

4.

After selecting "DIAGNOSTIC TROUBLE CODES(DTCs)" mode and check if DTC is recorded again.

5.

Are any DTCs recorded ?

YES

▶ Go to the DTC guide of recorded NO. in Scantool.

DIESEL CONTROL SYSTEM

FLA -421

NO

▶ System operates within specification.

FLA -422

FUEL SYSTEM

DTC P1670 INJECTOR CLASSIFICATION ERROR (DIESEL 1) / INJECTOR
SPECIFIC DATA ERROR (DIESEL 2)

COMPONENT LOCATION

E7699087

ECM

EGNG007T

GENERAL DESCRIPTION

E85F3145

IQA (Injector Quantity Adjustment) means adjusting fuel injection quantity difference between injectors which occurs in-
evitably at manufacturing process as allotting serial number consists of 7 letters to each injectors.Inputting IQA code of
injectors installed in each cylinder to ECM, ECM recognizes the fuel injection quantity difference between each injectors.
ECM adjusts every injector to have same fuel injecting characteristic as recognizing specific fuel injection map which is
different for each serial number.

IQA Mark

EGNG004T

DTC DESCRIPTION

EAA786C4

P1670 is set when ’IQA input error’ or ’saving error’ occurs in EEP ROM where IQA data is saved. This code is due to
ECM internal error.

 

 

 

 

 

 

 

Content   ..  135  136  137  138   ..