Dodge Neon / Neon SRT-4. Manual - part 575

 

  Index      Dodge     Dodge Neon / Neon SRT-4 - service repair manual 2005 year

 

Search            

 

 

 

 

 

 

 

 

 

Content   ..  573  574  575  576   ..

 

 

Dodge Neon / Neon SRT-4. Manual - part 575

 

 

TEST

ACTION

APPLICABILITY

5

Turn the ignition on.
With the DRBIII

t, display the VIN that is programmed in the PCM.

Was the correct VIN programmed into the PCM?

All

Yes

→ Go To 6

No

→ Replace and program the Powertrain Control Module in accor-

dance with the Service Information.
Perform SKIS VERIFICATION.

6

Turn the ignition off.
Replace and program the Sentry Key Immobilizer Module in accordance with the
Service Information.
Turn the ignition on.
With the DRBIII

t, erase all SKIM and PCM DTCs.

Attempt to start and idle the engine.
With the DRBIII

t, read the PCM DTCs.

Does the DRBIII

t display this code?

All

Yes

→ NOTE: Before continuing, check the PCM harness connector

termnals for corrosion, damage, or terminal push out. Repair as
necessary. Replace and program the Powertrain Control Module
in accordance with the Service Information.
Perform SKIS VERIFICATION.

No

→ Test Complete.

7

NOTE: You must obtain the SKIM pin number.
NOTE: This DTC could have been set if the SKIM harness connector was
disconnected, or if the SKIM was replaced recently.
NOTE: All keys that the customer uses for this vehicle must be tested to
verify they are operating properly.
Turn the ignition on.
Verify the correct VIN is programmed into the PCM and SKIM.
Turn the ignition off.
With the next customer key turn the ignition key on and crank the engine to start.
With the DRBIII

t, read the PCM DTCs. Look for P0513.

Is the Good Trip Counter for DTC P0513 displayed and equal to 0?

All

Yes

→ Replace the Ignition Key.

Perform SKIS VERIFICATION.

No

→ Test Complete.

NOTE: If this DTC cannot be reset, it could have been an actual theft
attempt.

205

DRIVEABILITY - NGC

P0513-INVALID SKIM KEY —

Continued

Symptom:

P0516-BATTERY TEMPERATURE SENSOR LOW

When Monitored and Set Condition:

P0516-BATTERY TEMPERATURE SENSOR LOW

When Monitored:

Ignition on.

Set Condition:

Battery temperature sensor voltage below 0.1 of a volt.

POSSIBLE CAUSES

BATTERY TEMP SENSOR VOLTAGE BELOW 0.1 VOLTS

BATTERY TEMP SENSOR INTERNAL FAILURE

(K118) BATTERY TEMP SIGNAL SHORTED TO GROUND

(K118) BATTERY TEMP SIGNAL SHORTED TO (K167) SENSOR GROUND CIRCUIT

PCM

TEST

ACTION

APPLICABILITY

1

NOTE: After repairing a Battery Temp DTC, the Battery Temp value will not
be refreshed until either the ignition is OFF for more than 3 hours or the
vehicle is driven above 10 MPH for more than 10 minutes.
Ignition on, engine not running.
With the DRBIII

t, read the Battery Temp Sensor voltage.

Is the voltage below 0.1 volt?

All

Yes

→ Go To 2

No

→ Refer to the INTERMITTENT CONDITION symptom in the

Driveability category.
Perform POWERTRAIN VERIFICATION TEST VER - 5.

2

Turn the ignition off.
Disconnect the Battery Temp Sensor harness connector.
Ignition on, engine not running.
With the DRBIII

t, read Battery Temp Sensor voltage.

Does the Battery Temp Sensor voltage read approximately 5.0 volts?

All

Yes

→ Replace the Battery Temperature Sensor.

Perform POWERTRAIN VERIFICATION TEST VER - 5.

No

→ Go To 3

206

DRIVEABILITY - NGC

TEST

ACTION

APPLICABILITY

3

Turn the ignition off.
Disconnect the Battery Temp Sensor harness connector.
Disconnect the PCM harness connector.
Measure the resistance between ground and the (K118) Battery Temp Signal circuit
in the Battery Temp Sensor harness connector.
Is the resistance below 100 ohms?

All

Yes

→ Repair the short to ground in the (K118) Battery Temp Signal

circuit.
Perform POWERTRAIN VERIFICATION TEST VER - 5.

No

→ Go To 4

4

Turn the ignition off.
Disconnect the Battery Temp Sensor harness connector.
Disconnect the PCM harness connector.
Measure the resistance between the (K118) Battery Temp Signal circuit and the
(K167) Sensor ground circuit in the Battery Temp Sensor harness connector.
Is the resistance below 100 ohms?

All

Yes

→ Repair the (K167) Sensor ground shorted to the (K118) Battery

Temp Sensor Signal circuit.
Perform POWERTRAIN VERIFICATION TEST VER - 5.

No

→ Go To 5

5

NOTE: Before continuing, check the PCM harness connector terminals for
corrosion, damage, or terminal push out. Repair as necessary.
If there are no possible causes remaining, view repair.

All

Repair

Replace and program the Powertrain Control Module in accor-
dance with the Service Information.
Perform POWERTRAIN VERIFICATION TEST VER - 5.

207

DRIVEABILITY - NGC

P0516-BATTERY TEMPERATURE SENSOR LOW —

Continued

Symptom:

P0517-BATTERY TEMPERATURE SENSOR HIGH

When Monitored and Set Condition:

P0517-BATTERY TEMPERATURE SENSOR HIGH

When Monitored:

Ignition on.

Set Condition:

Battery temperature voltage above 4.9 volts.

POSSIBLE CAUSES

BATTERY TEMP VOLTAGE ABOVE 4.9 VOLTS

(K118) BATTERY TEMP SIGNAL CIRCUIT SHORTED TO BATTERY VOLTAGE

BATTERY TEMP SENSOR INTERNAL FAILURE

(K118) BATTERY TEMP SIGNAL CIRCUIT OPEN

(K167) SENSOR GROUND CIRCUIT OPEN

PCM

TEST

ACTION

APPLICABILITY

1

NOTE: After repairing a Battery Temp DTC, the Battery Temp value will not
be refreshed until either the ignition is OFF for more than 3 hours or the
vehicle is driven above 10 MPH for more than 10 minutes.
Ignition on, engine not running.
With the DRBIII

t, read the Battery Temp Sensor voltage.

Is the voltage above 4.9 volts?

All

Yes

→ Go To 2

No

→ Refer to the INTERMITTENT CONDITION symptom in the

Driveability category.
Perform POWERTRAIN VERIFICATION TEST VER - 5.

2

Turn the ignition off.
Disconnect the Battery Temp Sensor harness connector.
Ignition on, engine not running.
Measure the voltage of the (K118) Battery Temp Signal circuit in the Battery Temp
Sensor harness connector.
Is the voltage above 5.2 volts?

All

Yes

→ Repair the short to battery voltage in the (K118) Battery Temp

Signal circuit.
Perform POWERTRAIN VERIFICATION TEST VER - 5.

No

→ Go To 3

208

DRIVEABILITY - NGC

 

 

 

 

 

 

 

Content   ..  573  574  575  576   ..