Seat Cordoba. Service Manual - part 15

 

  Index      Seat     Seat Cordoba. Service Manual

 

Search            copyright infringement  

 

 

 

 

 

 

 

 

Content      ..     13      14      15      16     ..

 

 

Seat Cordoba. Service Manual - part 15

 

 

-------------------------------------------------------------------------------------------------------------------------------------------------------------

230
General notes on the technical data
Weights
Drawbar load
The maximum permitted weight exerted by the trailer drawbar on the ball joint
Kerb weight refers to the basic model with a fuel tank filled to 90% capacity
of the towing bracket must not exceed 75 kg.
and without optional extras. The figure quoted includes 75 kg to allow for the
In the interest of road safety, we recommend that you always tow
weight of the driver.
approaching the maximum drawbar load. The response of the trailer on the
For special versions and optional equipment fittings or for the addition of
road will be poor if the drawbar load is too small.
accessories, the weight of the vehicle will increase ⇒
If the maximum permissible drawbar load cannot be met (e.g. with small,
empty and light-weight single axle trailers or tandem axle trailers with an axle
base of less than 1 metre), at least 4% of the actual trailer weight is a legal
WARNING
stipulation for a drawbar load.
• Please note that the centre of gravity may shift when transporting
heavy objects; this may affect the vehicle's handling and lead to an acci-
dent. Always adjust your speed and driving style to suit road conditions
WARNING
and requirements.
• For safety reasons, you should not drive at speeds above 80 km/h when
• Never exceed the gross axle weight rating or the gross vehicle weight
towing a trailer. This also applies to countries where higher speeds are
rating. If the allowed axle load or the allowed total weight is exceeded, the
permitted.
driving characteristics of the vehicle may change, leading to accidents,
• Never exceed the maximum trailer weights or the draw bar loading. If
injuries and damage to the vehicle.
the permissible axle load or the permissible total weight is exceeded, the
driving characteristics of the vehicle may change, leading to accidents,
injuries and damage to the vehicle.
Towing a trailer
Wheels
Trailer weights
Trailer weights
Tyre pressure, snow chains, wheel bolts
The trailer weights and drawbar loads approved are selected in intensive
trials according to precisely defined criteria. The approved trailer weights are
Tyre pressures
valid for vehicles in the EU for maximum speeds of 80 km/h (in certain
The sticker with the tyre pressure values can be found on the inside of the
circumstances up to 100 km/h). The figures may be different in other coun-
tank flap. The tyre pressure values given there are for cold tyres. The slightly
tries. All data in the official vehicle documents take precedence over these
raised pressures of warm tyres must not be reduced ⇒
data ⇒

-------------------------------------------------------------------------------------------------------------------------------------------------------------

General notes on the technical data
231
Snow chains
Snow chains are only permitted on the front wheels and only for tyres 155/80
R13; 165/70 R14 and 185/80 R14. Snow chains must have fine-pitch links
which do not protrude more than 15 mm, including tension device.
Remaining tyres can be fitted with chains no thicker than 9 mm.
Wheel bolts
After the wheels have been changed, the tightening torque of the wheel bolts
should be checked as soon as possible with a torque wrench ⇒ . The tight-
ening torque for steel and alloy wheels is 120 Nm.
WARNING
• Check the tyre pressure at least once per month. Correct tyre pressure
is very important. If the tyre pressure is too high or too low, there is an
increased danger of accidents, particularly at high speeds.
• If the torque of the wheel bolts is too low, they could loosen whilst the
vehicle is in motion. Risk of accident! If the tightening torque is too high,
the wheel bolts and threads could be damaged.
Note
We recommend that you ask your Authorised Service Centre for information
about appropriate wheel, tyre and snow chain size.
Safety First
Operating instructions
Tips and Maintenance
Technical Data

-------------------------------------------------------------------------------------------------------------------------------------------------------------

232
Technical Data
Technical Data
Overview
Checking fluid levels
Further explanations, instructions and restrictions on the technical data are
From time to time, the levels of the different fluids in the
contained as of ⇒ page 227.
vehicle must be checked. Never fill with incorrect fluids, to do
so may cause serious damage to the engine.
Note
The layout of parts may vary according to engine.
Fig. 161 Diagram for the
location of the various
elements
1
Radiator expansion tank
2
Engine oil dipstick.
3
Engine oil filler cap
4
Brake fluid reservoir
5
Battery
6
Windscreen washer fluid container
The checking and replenishment of the service fluids are carried out on the
components mentioned above. These operations are described in the
⇒ page 175.

-------------------------------------------------------------------------------------------------------------------------------------------------------------

Technical Data
233
Petrol engine 1.2 51 kW (69 bhp)
General engine data
Power output in kW (bhp)
rpm
51 (69)/ 5400
Maximum torque
in Nm at rpm
112/ 3000
No. of cylinders, capacity
in cm 3
3/ 1198
Compression
10,5+/- 0,3
Fuel
Super 95 RONa)/Normal 91 RONa)b)
a) Research-Octane- Number = Measure of the predetonation power of the petrol.
b) With a slight power loss
Performance figures
Maximum speed
in km/h
171
Acceleration from 0-80 km/h
in sec.
9,7
Acceleration from 0-100 km/h
in sec.
14,7
Weights
Gross vehicle weight
in kg
1580
Weight in working order (with driver)
in kg
1141
Gross axle weight, front
in kg
810
Gross axle weight, rear
in kg
830
Permitted roof load
in kg
75
Trailer weights
With no brakes, gradients up to 12%
500
With brakes, gradients up to 12%
800
Safety First
Operating instructions
Tips and Maintenance
Technical Data

-------------------------------------------------------------------------------------------------------------------------------------------------------------

234
Technical Data
Engine oil capacity
Approximate engine oil capacity with oil filter change
3.2 litres
Petrol engine 1.4 63 kW (86 bhp)
General engine data
Power output in kW (bhp)
rpm
63 (86)/ 5000
Maximum torque
in Nm at rpm
132/ 3600
No. of cylinders, capacity
in cm 3
4/ 1390
Compression
10,5 +/- 0,3
Fuel
Super 95 RONa)/Normal 91 RONb)
a) Research-Octane-Number = Measure of the predetonation power of the petrol.
b) Slight power loss
Performance figures
Maximum speed
in km/h
181
Acceleration from 0-80 km/h
in sec.
8,4
Acceleration from 0-100 km/h
in sec.
12,4

-------------------------------------------------------------------------------------------------------------------------------------------------------------

Technical Data
235
Weights
Gross vehicle weight
in kg
1594
Weight in working order (with driver)
in kg
1150
Gross axle weight, front
in kg
840
Gross axle weight, rear
in kg
800
Permitted roof load
in kg
75
Trailer weights
With no brakes, gradients up to 12%
500
With brakes, gradients up to 12%
800
Engine oil capacity
Approximate engine oil capacity with oil filter change
3.2 litres
Petrol engine 1.4 litre 55 kW (75 hp). Automatic
General engine data
Power output in kW (bhp)
rpm
55 (75)/ 5000
Maximum torque
in Nm at rpm
126/ 3800
No. of cylinders, capacity
in cm 3
4/ 1390
Compression
10,5
Fuel
Super 95 RONa)/Normal 91 RONb)
a) Research-Octane-Number = Measure of the predetonation power of the petrol.
b) With a slight power loss
Safety First
Operating instructions
Tips and Maintenance
Technical Data

-------------------------------------------------------------------------------------------------------------------------------------------------------------

236
Technical Data
Performance figures
Maximum speed
in km/h
172
Acceleration from 0-80 km/h
in sec.
10,3
Acceleration from 0-100 km/h
in sec.
15,9
Weights
Gross vehicle weight
in kg
1623
Weight in working order (with driver)
in kg
1182
Gross axle weight, front
in kg
847
Gross axle weight, rear
in kg
830
Permitted roof load
in kg
75
Trailer weights
With no brakes, gradients up to 12%
500
With brakes, gradients up to 12%
800
Engine oil capacity
Approximate engine oil capacity with oil filter change
3.5 litres

-------------------------------------------------------------------------------------------------------------------------------------------------------------

Technical Data
237
Petrol engine 1.4 74 kW (100 bhp)
General engine data
Power output in kW (bhp)
rpm
74 (100)/ 6000
Maximum torque
in Nm at rpm
126/ 4400
No. of cylinders, capacity
in cm 3
4/ 1390
Compression
10,5
Fuel
Super 98 RON/Super 95 RONa)b)
a) Research-Octane-Number = Measure of the predetonation power of the petrol.
b) Slight power loss
Performance figures
Maximum speed
in km/h
193
Acceleration from 0-80 km/h
in sec.
7,5
Acceleration from 0-100 km/h
in sec.
11,5
Weights
Gross vehicle weight
in kg
1585
Weight in working order (with driver)
in kg
1141
Gross axle weight, front
in kg
812
Gross axle weight, rear
in kg
835
Permitted roof load
in kg
75
Trailer weights
With no brakes, gradients up to 12%
500
With brakes, gradients up to 12%
1000
Safety First
Operating instructions
Tips and Maintenance
Technical Data

-------------------------------------------------------------------------------------------------------------------------------------------------------------

238
Technical Data
Engine oil capacity
Approximate engine oil capacity with oil filter change
3.5 litres
Petrol engine 1.6l 77 kW (105 bhp)
General engine data
Power output in kW (bhp)
rpm
77 (105)/ 5600
Maximum torque
in Nm at rpm
153/ 3800
No. of cylinders, capacity
in cm 3
4/ 1598
Compression
10,5 +/- 0,2
Fuel
95 super RONa)
a) Research-Octane-Number = Measure of the predetonation power of the petrol.
Performance figures
Maximum speed
in km/h
195
Acceleration from 0-80 km/h
in sec.
7,4
Acceleration from 0-100 km/h
in sec.
11,3
Weights
Gross vehicle weight
in kg
1604
Weight in working order (with driver)
in kg
1184
Gross axle weight, front
in kg
820
Gross axle weight, rear
in kg
835
Permitted roof load
in kg
75

-------------------------------------------------------------------------------------------------------------------------------------------------------------

Technical Data
239
Trailer weights
With no brakes, gradients up to 12%
550
With brakes, gradients up to 12%
1000
Engine oil capacity
Approximate engine oil capacity with oil filter change
4.0 litres
Diesel engine 1.4 litre TDI 51 kW (70 bhp)
General engine data
Power output in kW (bhp)
rpm
51 (70)/ 4000
Maximum torque
in Nm at rpm
195/2200
No. of cylinders, capacity
in cm 3
3/1422
Compression
19,5 ± 0,5
Fuel
Min. 51 CNa)
a) Cetane-Number (cetane index) = Measure of the combustion power of the diesel
Performance figures
Maximum speed
in km/h
167
Acceleration from 0-80 km/h
in sec.
9,8
Acceleration from 0-100 km/h
in sec.
15,2
Safety First
Operating instructions
Tips and Maintenance
Technical Data

-------------------------------------------------------------------------------------------------------------------------------------------------------------

240
Technical Data
Weights
Gross vehicle weight
in kg
1662
Weight in working order (with driver)
in kg
1219
Gross axle weight, front
in kg
887
Gross axle weight, rear
in kg
840
Permitted roof load
in kg
75
Trailer weights
With no brakes, gradients up to 12%
600
With brakes, gradients up to 12%
1200
Engine oil capacity
Approximate engine oil capacity with oil filter change
3.8 litres
Diesel engine 1.4 TDI 59 kW (80 bhp).
General engine data
Power output in kW (bhp)
rpm
59 (80)/ 4000
Maximum torque
in Nm at rpm
195/2200
No. of cylinders, capacity
in cm 3
3/1422
Compression
19,5 ± 0,5
Fuel
Min. 51 CNa)
a) Cetane-Number (cetane index) = Measure of the combustion power of the diesel.

-------------------------------------------------------------------------------------------------------------------------------------------------------------

Technical Data
241
Performance figures
Maximum speed
in km/h
177
Acceleration from 0-80 km/h
in sec.
8,9
Acceleration from 0-100 km/h
in sec.
13,2
Weights
Gross vehicle weight
in kg
1662
Weight in working order (with driver)
in kg
1219
Gross axle weight, front
in kg
887
Gross axle weight, rear
in kg
840
Permitted roof load
in kg
75
Trailer weights
With no brakes, gradients up to 12%
600
With brakes, gradients up to 12%
1200
Engine oil capacity
Approximate engine oil capacity with oil filter change
4.3 litres
Safety First
Operating instructions
Tips and Maintenance
Technical Data

-------------------------------------------------------------------------------------------------------------------------------------------------------------

242
Technical Data
Diesel engine 1.9l TDI 74 kW (100 bhp)
General engine data
Power output in kW (bhp)
rpm
74(100)/ 4000
Maximum torque
in Nm at rpm
240/ 1800-2400
No. of cylinders, capacity
in cm 3
4/ 1896
Compression
19
Fuel
Min. 51 CNa)
a) Cetane-Number (cetane index) = Measure of the combustion power of the diesel.
Performance figures
Maximum speed
in km/h
192
Acceleration from 0-80 km/h
in sec.
7,6
Acceleration from 0-100 km/h
in sec.
11,1
Weights
Gross vehicle weight
in kg
1683
Weight in working order (with driver)
in kg
1263
Gross axle weight, front
in kg
882
Gross axle weight, rear
in kg
825
Permitted roof load
in kg
75
Trailer weights
With no brakes, gradients up to 12%
600
With brakes, gradients up to 12%
1200

-------------------------------------------------------------------------------------------------------------------------------------------------------------

Technical Data
243
Engine oil capacity
Approximate engine oil capacity with oil filter change
4.3 litres
Diesel engine 1.9l TDI 96 kW (131 bhp)
General engine data
Power output in kW (bhp)
rpm
96(131)/ 4000
Maximum torque
in Nm at rpm
310/ 1900
No. of cylinders, capacity
in cm 3
4/ 1896
Compression
19
Fuel
Min. 51CZa)
a) Cetane-Number (cetane index) = Measure of the combustion power of the diesel.
Performance figures
Maximum speed
in km/h
210
Acceleration from 0-80 km/h
in sec.
6,6
Acceleration from 0-100 km/h
in sec.
9,5
Weights
Gross vehicle weight
in kg
1733
Weight in working order (with driver)
in kg
1313
Gross axle weight, front
in kg
955
Gross axle weight, rear
in kg
830
Permitted roof load
in kg
75
Safety First
Operating instructions
Tips and Maintenance
Technical Data

-------------------------------------------------------------------------------------------------------------------------------------------------------------

244
Technical Data
Trailer weights
With no brakes, gradients up to 12%
600
With brakes, gradients up to 12%
1200
Engine oil capacity
Engine oil capacity with oil filter change.
4.3 litres

-------------------------------------------------------------------------------------------------------------------------------------------------------------

Technical Data
245
Dimensions and capacities
Dimensions
Length, width
4,280 mm/ 1,698 mm
Height at kerb weight
1,447 mm
Front and rear projection
831 mm/ 839 mm
Wheelbase
2,460 mm
Turning circle
10.54 m
Front
Rear
Track widtha)
1,435 mm
1,424 mm
1,419 mm
1,408 mm
Capacities
Fuel tank
45 litres, reserve 7 litres.
Windscreen washer fluid container with headlight washer
2 l/ 4.5 l
Tyre pressure
Summer-grade tyres:
The correct tyre pressure can be seen on the sticker on the inside of the tank flap.
Winter tyres:
The pressure of these tyres is the same as the summer tyre pressure plus 0.2 bar.
a) This data will change depending on the type of wheel rim.
Safety First
Operating instructions
Tips and Maintenance
Technical Data

 

 

 

 

 

 

 

Content      ..     13      14      15      16     ..