|
|
|
The following abbreviations are used to represent values for Control Module Pin-Out data
I
Input
D
Serial and Encoded Data
B+
Battery Voltage
kHz
Frequency x 1000
O
Output
C
CAN (Network)
V
Voltage (DC)
ms
Milliseconds
SG
Signal Ground
S
SCP Network
Hz
Frequency
mV
Millivolts
CAUTION: The information on this data page is furnished to aid the user in understanding circuit operation.
THIS INFORMATION SHOULD BE USED FOR
REFERENCE ONLY.
NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all
components connected and fitted.
“Active” means a load is applied or a switch is ON; “Inactive” means a load is not applied or a switch is OFF.
Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, grounds, control
modules and control module pins.
DATE OF ISSUE:
October 1999
Fig. 20.1
COMPONENTS
Component
Connector / Type / Color
Location / Access
BODY PROCESSOR MODULE
FC15 / 14-WAY AMP EEEC / GREY
BULKHEAD / BEHIND GLOVE BOX
CIGAR LIGHTER – FRONT
CA74 / 3-WAY MULTILOCK 070 / WHITE
CENTER CONSOLE ASSEMBLY
CIGAR LIGHTER – REAR
CA75 / 2-WAY AMP / METALLIC
REAR CENTER CONSOLE VENT
CA76 / 1-WAY LUCAR POSILOCK MKI / BLACK
FUSE BOX – ENGINE COMPARTMENT
LF5 / 10-WAY U.T.A. FUSE BOX / NATURAL
ENGINE COMPARTMENT / LH FRONT
LF6 / 10-WAY U.T.A. FUSE BOX / BLACK
LF7 / 10-WAY U.T.A. FUSE BOX / GREEN
LF8 / 10-WAY U.T.A. FUSE BOX / BLUE
ST19 / EYELET
FUSE BOX – TRUNK
BT10 / 10-WAY U.T.A. FUSE BOX / NATURAL
TRUNK ELECTRICAL CARRIER
BT11 / 10-WAY U.T.A. FUSE BOX / BLACK
BT12 / 10-WAY U.T.A. FUSE BOX / GREEN
BT13 / 10-WAY U.T.A. FUSE BOX / BLUE
BT64 / EYELET
HORN SWITCHES (STEERING WHEEL)
HP1 / 1-WAY BLADE
CENTER OF STEERING WHEEL
HP2 / 1-WAY BLADE
HORN – LH
LF46 / 1-WAY LUCAR POSILOCK MKI / BLACK
FORWARD OF RADIATOR – LH SIDE / RADIATOR GRILLE
LF47 / 1-WAY LUCAR POSILOCK MKI / BLACK
HORN – RH
LF48 / 1-WAY LUCAR POSILOCK MKI / BLACK
FORWARD OF RADIATOR – RH SIDE / RADIATOR GRILLE
LF49 / 1-WAY LUCAR POSILOCK MKI / BLACK
PASSENGER COMPARTMENT ACCESSORY CONNECTOR
CA71 / 3-WAY AMP SERIES 250 PIN / BLACK
RH HEELBOARD / HEELBOARD COVER
TRUNK ACCESSORY CONNECTOR
BT25 / 3-WAY AMP SERIES 250 PIN / BLACK
ADJACENT TO BATTERY / BATTERY COVER
RELAYS
Relay
Case Color
Connector / Color
Location / Access
HORN RELAY
BROWN
BUS
RELAY #6, ENGINE COMPARTMENT FUSE BOX / ENGINE COMPARTMENT
ACCESSORY CONNECTOR RELAY
BROWN
BUS
RELAY #6, TRUNK FUSE BOX / TRUNK
HARNESS-TO-HARNESS CONNECTORS
Connector
Type / Color
Location / Access
BT4
54-WAY THROUGH PANEL / GREY
BELOW PARCEL SHELF / TRUNK / REAR BULKHEAD / RH SIDE
EM1
12-WAY AUGAT 1.6 / BLACK
ENGINE COMPARTMENT / ADJACENT TO ABS PUMP
EM3
18-WAY MULTILOCK 070 / WHITE
PASSENGER ‘A’ POST / LOWER ‘A’ POST FINISHER
SC2
10-WAY MULTILOCK 070 / YELLOW
ADJACENT TO STEERING COLUMN MOTOR
SC3
12-WAY MULTILOCK 070 / GREY
ADJACENT TO STEERING COLUMN MOTOR
SW1
12-WAY MULTILOCK 040 / BLACK
INSIDE STEERING COLUMN COWL
SW2
6-WAY JST / BLACK
CENTER OF STEERING WHEEL
GROUNDS
Ground
Location / Type
BT21R
EYELET (PAIR) – TRUNK / RH REAR GROUND STUD
CA31R
EYELET (PAIR) – RH DRIVE SHAFT TUNNEL GROUND STUD
CA47L
EYELET (PAIR) – DRIVE SHAFT TUNNEL GROUND STUD – RH SIDE
CA47R
EYELET (PAIR) – DRIVE SHAFT TUNNEL GROUND STUD – RH SIDE
FC17R
EYELET (PAIR) – EMS BULKHEAD GROUND STUD
LF18R
EYELET (PAIR) – LH FORWARD GROUND STUD
LF20R
EYELET (PAIR) – RH FORWARD GROUND STUD
FOR CONTROL MODULE PIN OUT INFORMATION, UNFOLD PAGE TO LEFT.
CONTROL MODULE PIN OUT INFORMATION
BODY PROCESSOR MODULE
P
Pin
Description
Active
Inactive
I
FC15-4
HORN ACTIVATE REQUEST
GROUND (MOMENTARY)
B+
O
FC15-70
HORN RELAY ACTIVATE
GROUND (MOMENTARY)
B+
I
FC15-80
BATTERY SUPPLY VOLTAGE
B+
B+
The following abbreviations are used to represent values for Control Module Pin-Out data
I
Input
D
Serial and Encoded Data
B+
Battery Voltage
kHz
Frequency x 1000
O
Output
C
CAN (Network)
V
Voltage (DC)
ms
Milliseconds
SG
Signal Ground
S
SCP Network
Hz
Frequency
mV
Millivolts
CAUTION: The information on this data page is furnished to aid the user in understanding circuit operation.
THIS INFORMATION SHOULD BE USED FOR
REFERENCE ONLY.
NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all
components connected and fitted.
“Active” means a load is applied or a switch is ON; “Inactive” means a load is not applied or a switch is OFF.
Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, grounds, control
modules and control module pins.
DATE OF ISSUE:
October 1999
Fig. 21.1
COMPONENTS
Component
Connector / Type / Color
Location / Access
ABS / TRACTION CONTROL CONTROL MODULE
LF27 / 25-WAY AMP / FORD / BLACK
ENGINE COMPARTMENT / BEHIND LH HEADLAMP ASSEMBLY
BODY PROCESSOR MODULE
FC15 / 14-WAY AMP EEEC / GREY
BULKHEAD / BEHIND GLOVE BOX
DATA LINK CONNECTOR
CC6 / 16-WAY AMP (OBD2) / BLACK
TRANSMISSION TUNNEL
DOOR CONTROL MODULE – DRIVER
DD10 / 22-WAY FORD 2.8 TIMER / BLUE
DOOR CASING / TRIM PANEL
DD11 / 22-WAY FORD 2.8 TIMER / BLACK
DOOR CONTROL MODULE – DRIVER REAR
RD10 / 22-WAY FORD 2.8 TIMER / BLUE
DOOR CASING / TRIM PANEL
RD11 / 22-WAY FORD 2.8 TIMER / BLACK
DOOR CONTROL MODULE – PASSENGER
PD10 / 22-WAY FORD 2.8 TIMER / BLUE
DOOR CASING / TRIM PANEL
PD11 / 22-WAY FORD 2.8 TIMER / BLACK
DOOR CONTROL MODULE – PASSENGER REAR
RP10 / 22-WAY FORD 2.8 TIMER / BLUE
DOOR CASING / TRIM PANEL
RP11 / 22-WAY FORD 2.8 TIMER / BLACK
ENGINE CONTROL MODULE
EM80 / 31-WAY AMP 403 / NATURAL
ENGINE COMPARTMENT / CONTROL MODULE ENCLOSURE
EM81 / 24-WAY AMP 403 / NATURAL
EM82 / 17-WAY AMP 403 / NATURAL
EM83 / 28-WAY AMP 403 / NATURAL
EM84 / 22-WAY AMP 403 / NATURAL
EM85 / 12-WAY MULTILOCK 070 / WHITE
GEAR SELECTOR ILLUMINATION MODULE
CC14 / 10-WAY MULTILOCK 070 / WHITE
CENTER CONSOLE ASSEMBLY
INSTRUMENT PACK
FC24 / 26-WAY AMP MICRO QUAD LOCK / BLACK
FASCIA
FC25 / 26-WAY AMP MICRO QUAD LOCK / YELLOW
SEAT CONTROL MODULE – DRIVER
SD1 / 16-WAY FORD 2.8 TIMER / BLACK
DRIVER SEAT / UNDER
SD2 / 26-WAY FORD IDC / BLACK
SD3 / 10-WAY FORD 2.8 TIMER / BLACK
SEAT CONTROL MODULE – PASSENGER
SP1 / 16-WAY FORD 2.8 TIMER / BLACK
PASSENGER SEAT / UNDER
SP3 / 10-WAY FORD 2.8 TIMER / BLACK
SPLICE HEADER – CA222
CA222 / 20-WAY SUMITOMO SPLICE HEADER / GREY
RH HEELBOARD / HEELBOARD COVER
SPLICE HEADER – CA223
CA223 / 20-WAY SUMITOMO SPLICE HEADER / BLACK
RH HEELBOARD / HEELBOARD COVER
TRANSMISSION CONTROL MODULE: AJ27 N/A
EM7 / 88-WAY BOSCH / BLACK
ENGINE COMPARTMENT / CONTROL MODULE ENCLOSURE
TRANSMISSION CONTROL MODULE: AJ27 SC
EM61 / 18-WAY AMP JUNIOR POWER TIMER / BLACK
ENGINE COMPARTMENT / CONTROL MODULE ENCLOSURE
EM62 / 14-WAY AMP JUNIOR POWER TIMER / BLACK
VEHICLE SPEED INTERFACE MODULE
NV1 / 42-WAY SIEMENS / BLUE
ABOVE PASSENGER FOOTWELL
HARNESS-TO-HARNESS CONNECTORS
Connector
Type / Color
Location / Access
BT4
54-WAY THROUGH PANEL / GREY
BELOW PARCEL SHELF / TRUNK / REAR BULKHEAD / RH SIDE
CA8
20-WAY MULTILOCK 070 / WHITE
DRIVER ‘A’ POST / DOOR HARNESS GAITER
CA11
20-WAY MULTILOCK 070 / WHITE
PASSENGER ‘A’ POST / DOOR HARNESS GAITER
CA19
20-WAY MULTILOCK 070 / YELLOW
LH ‘A’ POST CONNECTOR MOUNTING BRACKET / LOWER ‘A’ POST FINISHER
CA23
10-WAY MULTILOCK 070 / WHITE
BELOW DRIVER SEAT
CA27
10-WAY MULTILOCK 070 / WHITE
BELOW PASSENGER SEAT
CA45
6-WAY MULTILOCK 070 / WHITE
PASSENGER ‘B/C’ POST / DOOR HARNESS GAITER
CA46
4-WAY MULTILOCK 070 / WHITE
DRIVER ‘B/C’ POST / DOOR HARNESS GAITER
EM1
12-WAY AUGAT 1.6 / BLACK
ENGINE COMPARTMENT / ADJACENT TO ABS PUMP
EM2
20-WAY MULTILOCK 070 / GREY
PASSENGER ‘A’ POST / LOWER ‘A’ POST FINISHER
FC1
54-WAY THROUGH PANEL CONNECTOR / GREY
BELOW PASSENGER SIDE AIR VENT / GLOVE BOX ASSEMBLY
FC7
20-WAY MULTILOCK 070 / YELLOW
ABOVE DIMMER MODULE / COIN TRAY
FC11
18-WAY MULTILOCK 070 / WHITE
ABOVE DIMMER MODULE / COIN TRAY
GROUNDS
Ground
Location / Type
CC3L
EYELET (PAIR) – RH FRONT BULKHEAD STUD / CABIN SIDE
NOTE: Refer to the Appendix at the rear of this book for CAN and SCP Network messages.
Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, grounds, control
modules and control module pins.
DATE OF ISSUE:
October 1999
Fig. 21.2
COMPONENTS
Component
Connector / Type / Color
Location / Access
ABS / TRACTION CONTROL CONTROL MODULE
LF27 / 25-WAY AMP / FORD / BLACK
ENGINE COMPARTMENT / BEHIND LH HEADLAMP ASSEMBLY
BODY PROCESSOR MODULE
FC15 / 14-WAY AMP EEEC / GREY
BULKHEAD / BEHIND GLOVE BOX
DATA LINK CONNECTOR
CC6 / 16-WAY AMP (OBD2) / BLACK
TRANSMISSION TUNNEL
DOOR CONTROL MODULE – DRIVER
DD10 / 22-WAY FORD 2.8 TIMER / BLUE
DOOR CASING / TRIM PANEL
DD11 / 22-WAY FORD 2.8 TIMER / BLACK
DOOR CONTROL MODULE – DRIVER REAR
RD10 / 22-WAY FORD 2.8 TIMER / BLUE
DOOR CASING / TRIM PANEL
RD11 / 22-WAY FORD 2.8 TIMER / BLACK
DOOR CONTROL MODULE – PASSENGER
PD10 / 22-WAY FORD 2.8 TIMER / BLUE
DOOR CASING / TRIM PANEL
PD11 / 22-WAY FORD 2.8 TIMER / BLACK
DOOR CONTROL MODULE – PASSENGER REAR
RP10 / 22-WAY FORD 2.8 TIMER / BLUE
DOOR CASING / TRIM PANEL
RP11 / 22-WAY FORD 2.8 TIMER / BLACK
ENGINE CONTROL MODULE
EM80 / 31-WAY AMP 403 / NATURAL
ENGINE COMPARTMENT / CONTROL MODULE ENCLOSURE
EM81 / 24-WAY AMP 403 / NATURAL
EM82 / 17-WAY AMP 403 / NATURAL
EM83 / 28-WAY AMP 403 / NATURAL
EM84 / 22-WAY AMP 403 / NATURAL
EM85 / 12-WAY MULTILOCK 070 / WHITE
GEAR SELECTOR ILLUMINATION MODULE
CC14 / 10-WAY MULTILOCK 070 / WHITE
CENTER CONSOLE ASSEMBLY
INSTRUMENT PACK
FC24 / 26-WAY AMP MICRO QUAD LOCK / BLACK
FASCIA
FC25 / 26-WAY AMP MICRO QUAD LOCK / YELLOW
SEAT CONTROL MODULE – DRIVER
SD1 / 16-WAY FORD 2.8 TIMER / BLACK
DRIVER SEAT / UNDER
SD2 / 26-WAY FORD IDC / BLACK
SD3 / 10-WAY FORD 2.8 TIMER / BLACK
SEAT CONTROL MODULE – PASSENGER
SP1 / 16-WAY FORD 2.8 TIMER / BLACK
PASSENGER SEAT / UNDER
SP3 / 10-WAY FORD 2.8 TIMER / BLACK
SPLICE HEADER – CA222
CA222 / 20-WAY SUMITOMO SPLICE HEADER / GREY
RH HEELBOARD / HEELBOARD COVER
SPLICE HEADER – CA223
CA223 / 20-WAY SUMITOMO SPLICE HEADER / BLACK
RH HEELBOARD / HEELBOARD COVER
TRANSMISSION CONTROL MODULE: AJ27 N/A
EM7 / 88-WAY BOSCH / BLACK
ENGINE COMPARTMENT / CONTROL MODULE ENCLOSURE
TRANSMISSION CONTROL MODULE: AJ27 SC
EM61 / 18-WAY AMP JUNIOR POWER TIMER / BLACK
ENGINE COMPARTMENT / CONTROL MODULE ENCLOSURE
EM62 / 14-WAY AMP JUNIOR POWER TIMER / BLACK
VEHICLE SPEED INTERFACE MODULE
NV1 / 42-WAY SIEMENS / BLUE
ABOVE PASSENGER FOOTWELL
HARNESS-TO-HARNESS CONNECTORS
Connector
Type / Color
Location / Access
BT4
54-WAY THROUGH PANEL / GREY
BELOW PARCEL SHELF / TRUNK / REAR BULKHEAD / RH SIDE
CA8
20-WAY MULTILOCK 070 / WHITE
DRIVER ‘A’ POST / DOOR HARNESS GAITER
CA11
20-WAY MULTILOCK 070 / WHITE
PASSENGER ‘A’ POST / DOOR HARNESS GAITER
CA19
20-WAY MULTILOCK 070 / YELLOW
LH ‘A’ POST CONNECTOR MOUNTING BRACKET / LOWER ‘A’ POST FINISHER
CA23
10-WAY MULTILOCK 070 / WHITE
BELOW DRIVER SEAT
CA27
10-WAY MULTILOCK 070 / WHITE
BELOW PASSENGER SEAT
CA45
6-WAY MULTILOCK 070 / WHITE
PASSENGER ‘B/C’ POST / DOOR HARNESS GAITER
CA46
4-WAY MULTILOCK 070 / WHITE
DRIVER ‘B/C’ POST / DOOR HARNESS GAITER
EM1
12-WAY AUGAT 1.6 / BLACK
ENGINE COMPARTMENT / ADJACENT TO ABS PUMP
EM2
20-WAY MULTILOCK 070 / GREY
PASSENGER ‘A’ POST / LOWER ‘A’ POST FINISHER
FC1
54-WAY THROUGH PANEL CONNECTOR / GREY
BELOW PASSENGER SIDE AIR VENT / GLOVE BOX ASSEMBLY
FC7
20-WAY MULTILOCK 070 / YELLOW
ABOVE DIMMER MODULE / COIN TRAY
FC11
18-WAY MULTILOCK 070 / WHITE
ABOVE DIMMER MODULE / COIN TRAY
GROUNDS
Ground
Location / Type
CC3L
EYELET (PAIR) – RH FRONT BULKHEAD STUD / CABIN SIDE
NOTE: Refer to the Appendix at the rear of this book for CAN and SCP Network messages.
The following abbreviations are used to represent values for Control Module Pin-Out data
I
Input
D
Serial and Encoded Data
B+
Battery Voltage
kHz
Frequency x 1000
O
Output
C
CAN (Network)
V
Voltage (DC)
ms
Milliseconds
SG
Signal Ground
S
SCP Network
Hz
Frequency
mV
Millivolts
CAUTION: The information on this data page is furnished to aid the user in understanding circuit operation.
THIS INFORMATION SHOULD BE USED FOR
REFERENCE ONLY.
NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all
components connected and fitted.
“Active” means a load is applied or a switch is ON; “Inactive” means a load is not applied or a switch is OFF.
Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, grounds, control
modules and control module pins.
DATE OF ISSUE:
October 1999
Fig. 21.3
COMPONENTS1
Component
Connector / Type / Color
Location / Access
ADAPTIVE DAMPING CONTROL MODULE
EM68 / 35-WAY AMP JUNIOR POWER TIMER / BLACK
ADJACENT TO PASSENGER SIDE BLOWER /
GLOVE BOX ASSEMBLY
AIR CONDITIONING CONTROL MODULE
CC28 / 26-WAY MULTILOCK 47 / GREY
RH SIDE OF TRANSMISSION TUNNEL / GLOVE BOX ASSEMBLY
CC29 / 16-WAY MULTILOCK 47 / GREY
CC30 / 12-WAY MULTILOCK 47 / GREY
CC31 / 22-WAY MULTILOCK 47 / GREY
AIR CONDITIONING CONTROL PANEL
CC27 / 12-WAY MULTILOCK 040 / BLUE
CENTER CONSOLE
AIRBAG / SRS SINGLE POINT SENSOR
CA61 / 50-WAY ELO50 / YELLOW
BELOW CENTER CONSOLE ASSEMBLY
BODY PROCESSOR MODULE
FC15 / 14-WAY AMP EEEC / GREY
BULKHEAD / BEHIND GLOVE BOX
DATA LINK CONNECTOR
CC6 / 16-WAY AMP (OBD2) / BLACK
TRANSMISSION TUNNEL
ENGINE CONTROL MODULE
EM80 / 31-WAY AMP 403 / NATURAL
ENGINE COMPARTMENT / CONTROL MODULE ENCLOSURE
EM81 / 24-WAY AMP 403 / NATURAL
EM82 / 17-WAY AMP 403 / NATURAL
EM83 / 28-WAY AMP 403 / NATURAL
EM84 / 22-WAY AMP 403 / NATURAL
EM85 / 12-WAY MULTILOCK 070 / WHITE
KEY TRANSPONDER MODULE
FC22 / 20-WAY MULTILOCK 040 / GREEN
BELOW INSTRUMENT PACK
HARNESS-TO-HARNESS CONNECTORS
Connector
Type / Color
Location / Access
CA19
20-WAY MULTILOCK 070 / YELLOW
LH ‘A’ POST CONNECTOR MOUNTING BRACKET / LOWER ‘A’ POST FINISHER
EM2
20-WAY MULTILOCK 070 / GREY
PASSENGER ‘A’ POST / LOWER ‘A’ POST FINISHER
EM3
18-WAY MULTILOCK 070 / WHITE
PASSENGER ‘A’ POST / LOWER ‘A’ POST FINISHER
EM53
20-WAY MULTILOCK 070 / WHITE
PASSENGER ‘A’ POST / LOWER ‘A’ POST FINISHER
FC11
18-WAY MULTILOCK 070 / WHITE
ABOVE DIMMER MODULE / COIN TRAY
GROUNDS
Ground
Location / Type
CC3L
EYELET (PAIR) – RH FRONT BULKHEAD STUD / CABIN SIDE
|
|
|