|
|
|
The following abbreviations are used to represent values for Control Module Pin-Out data
I
Input
D
Serial and Encoded Data
B+
Battery Voltage
kHz
Frequency x 1000
O
Output
C
CAN (Network)
V
Voltage (DC)
ms
Milliseconds
SG
Signal Ground
S
SCP Network
Hz
Frequency
mV
Millivolts
CAUTION: The information on this data page is furnished to aid the user in understanding circuit operation.
THIS INFORMATION SHOULD BE USED FOR
REFERENCE ONLY.
NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all
components connected and fitted.
“Active” means a load is applied or a switch is ON; “Inactive” means a load is not applied or a switch is OFF.
Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, grounds, control
modules and control module pins.
DATE OF ISSUE:
October 1999
Fig. 14.1
COMPONENTS
Component
Connector / Type / Color
Location / Access
BODY PROCESSOR MODULE
FC15 / 14-WAY AMP EEEC / GREY
BULKHEAD / BEHIND GLOVE BOX
FUSE BOX – ENGINE COMPARTMENT
LF5 / 10-WAY U.T.A. FUSE BOX / NATURAL
ENGINE COMPARTMENT / LH FRONT
LF6 / 10-WAY U.T.A. FUSE BOX / BLACK
LF7 / 10-WAY U.T.A. FUSE BOX / GREEN
LF8 / 10-WAY U.T.A. FUSE BOX / BLUE
ST19 / EYELET
INTERIOR REAR VIEW MIRROR
CA55 / 8-WAY MULTILOCK 070 / YELLOW
WINDSHIELD / IN FRONT OF ROOF CONSOLE
LIGHTING STALK (COLUMN SWITCHGEAR)
SC2 / 10-WAY MULTILOCK 070 / YELLOW
COLUMN SWITCHGEAR HARNESS /
ADJACENT TO STEERING COLUMN MOTOR
POWER WASH PUMP
LF43 / 2-WAY REINSHAGEN / VOLKSWAGEN / BLACK
RIGHT FRONT QUARTER PANEL / WASHER FLUID CONTAINER
RAIN SENSING MODULE
EM72 / 12-WAY AMP ML42 / BLACK
ENGINE COMPARTMENT / CONTROL MODULE ENCLOSURE
RAIN SENSOR
NO CODES / 3-WAY AMP MICRO QUAD LOCK / BLACK
BEHIND INTERIOR REAR VIEW MIRROR
WASH / WIPE STALK (COLUMN SWITCHGEAR)
SC1 / 12-WAY MULTILOCK 070 / WHITE
COLUMN SWITCHGEAR HARNESS /
ADJACENT TO STEERING COLUMN MOTOR
WINDSHIELD WASH PUMP AND FLUID LEVEL SENSOR
LF44 / 3-WAY AUGAT 1.6 / BLACK
RIGHT FRONT QUARTER PANEL / WASHER FLUID CONTAINER
WIPER MOTOR
EM33 / 4-WAY AUGAT 1.6 / BLACK
ENGINE COMPARTMENT / BULKHEAD
RELAYS
Relay
Case Color
Connector / Color
Location / Access
WIPER RUN / STOP RELAY
BLACK
LF11 / BLACK
ENGINE COMPARTMENT FRONT RELAYS / ENGINE COMPARTMENT
WIPER FAST / SLOW RELAY
BLACK
LF11 / BLACK
ENGINE COMPARTMENT FRONT RELAYS / ENGINE COMPARTMENT
POWERWASH RELAY
BROWN
BUS
RELAY #4, ENGINE COMPARTMENT FUSE BOX / ENGINE COMPARTMENT
HARNESS-TO-HARNESS CONNECTORS
Connector
Type / Color
Location / Access
EM3
18-WAY MULTILOCK 070 / WHITE
PASSENGER ‘A’ POST / LOWER ‘A’ POST FINISHER
EM51
12-WAY AUGAT 1.6 / GREY
ENGINE COMPARTMENT / ADJACENT TO ABS PUMP
FC5
54-WAY THROUGH PANEL CONNECTOR / GREY
BELOW DRIVER SIDE AIR VENT / COIN TRAY
LF3
54-WAY THROUGH PANEL CONNECTOR / GREY
LH ‘A’ POST / LOWER ‘A’ POST FINISHER
GROUNDS
Ground
Location / Type
EM8L
EYELET (PAIR) – EMS LH GROUND STUD
EM17
EYELET (SINGLE) – EMS BULKHEAD GROUND STUD
FC17R
EYELET (PAIR) – EMS BULKHEAD GROUND STUD
LF18R
EYELET (PAIR) – LH FORWARD GROUND STUD
LF19L
EYELET (PAIR) – RH FORWARD GROUND STUD
FOR CONTROL MODULE PIN OUT INFORMATION, UNFOLD PAGE TO LEFT.
CONTROL MODULE PIN OUT INFORMATION
BODY PROCESSOR MODULE
P
Pin
Description
Active
Inactive
I
FC15-6
WASHER FLUID LEVEL SENSOR
GROUND (FULL)
B+ (EMPTY)
I
FC15-9
VARIABLE INTERMITTENT WIPE REQUEST
I
FC15-15
IGNITION SWITCHED GROUND
GROUND
B+
I
FC15-16
SIDE LAMP REQUEST
GROUND
B+
O
FC15-18
POWER WASH RELAY ACTIVATE
GROUND
B+
O
FC15-19
WIPER FAST / SLOW RELAY ACTIVATE
GROUND (FAST)
B+ (SLOW)
O
FC15-26
WINDSHIELD WASHER PUMP ACTIVATE
B+
GROUND
I
FC15-34
FAST WIPE SPEED REQUEST
GROUND
B+
I
FC15-37
PROGRAMMED WASH REQUEST
GROUND (MOMENTARY)
B+
O
FC15-43
WIPER RUN / STOP RELAY ACTIVATE
GROUND
B+
I
FC15-60
WIPER MOTOR PARK SWITCH STATUS
GROUND (PARKED)
B+ (NOT PARKED)
I
FC15-80
BATTERY SUPPLY VOLTAGE
B+
B+
I
FC15-94
SLOW / FLICK WIPE REQUEST
GROUND
B+
I
FC15-104
BATTERY SUPPLY VOLTAGE
B+
B+
The following abbreviations are used to represent values for Control Module Pin-Out data
I
Input
D
Serial and Encoded Data
B+
Battery Voltage
kHz
Frequency x 1000
O
Output
C
CAN (Network)
V
Voltage (DC)
ms
Milliseconds
SG
Signal Ground
S
SCP Network
Hz
Frequency
mV
Millivolts
CAUTION: The information on this data page is furnished to aid the user in understanding circuit operation.
THIS INFORMATION SHOULD BE USED FOR
REFERENCE ONLY.
NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all
components connected and fitted.
“Active” means a load is applied or a switch is ON; “Inactive” means a load is not applied or a switch is OFF.
Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, grounds, control
modules and control module pins.
DATE OF ISSUE:
October 1999
Fig. 15.1
COMPONENTS
Component
Connector / Type / Color
Location / Access
BODY PROCESSOR MODULE
FC15 / 14-WAY AMP EEEC / GREY
BULKHEAD / BEHIND GLOVE BOX
CENTRAL LOCKING SWITCH
CC1 / 16-WAY FORD IDC S.U. / BLACK
CENTER CONSOLE SWITCH PACK
(CENTER CONSOLE SWITCH PACK)
DOOR CONTROL MODULE – DRIVER
DD10 / 22-WAY FORD 2.8 TIMER / BLUE
DOOR CASING / TRIM PANEL
DD11 / 22-WAY FORD 2.8 TIMER / BLACK
DOOR CONTROL MODULE – DRIVER REAR
RD10 / 22-WAY FORD 2.8 TIMER / BLUE
DOOR CASING / TRIM PANEL
RD11 / 22-WAY FORD 2.8 TIMER / BLACK
DOOR CONTROL MODULE – PASSENGER
PD10 / 22-WAY FORD 2.8 TIMER / BLUE
DOOR CASING / TRIM PANEL
PD11 / 22-WAY FORD 2.8 TIMER / BLACK
DOOR CONTROL MODULE – PASSENGER REAR
RP10 / 22-WAY FORD 2.8 TIMER / BLUE
DOOR CASING / TRIM PANEL
RP11 / 22-WAY FORD 2.8 TIMER / BLACK
DOOR LOCK SWITCHES – DRIVER
DD3 / 13-WAY ECONOSEAL III LC / BLACK
DOOR CASING / TRIM PANEL
INSTRUMENT PACK
FC24 / 26-WAY AMP MICRO QUAD LOCK / BLACK
FASCIA
FC25 / 26-WAY AMP MICRO QUAD LOCK / YELLOW
KEY FOB ANTENNA
BT33 / 1-WAY COAXIAL CONNECTOR / BLACK
TOP OF BACKLIGHT
REAR WINDOW INHIBIT SWITCH
DD1 / 26-WAY AMP MICRO QUAD LOCK / YELLOW
DOOR TRIM PANEL
(DRIVER DOOR SWITCH PACK)
SECURITY AND LOCKING CONTROL MODULE
BT1 / 16-WAY FORD 2.8 TIMER / BLACK
BELOW TRUNK FUSE BOX
BT2 / 26-WAY FORD IDC / BLACK
BT6 / 2-WAY COAXIAL CONNECTOR / BLACK
SLIDING ROOF CONTROL MODULE
CA64 / 6-WAY MULTILOCK 070 / WHITE
ROOF CONSOLE
SLIDING ROOF MOTOR
SR2 / 3-WAY MULTILOCK 070 / WHITE
ROOF CONSOLE
SLIDING ROOF SWITCH
CA53 / 8-WAY MULTILOCK 040 / BLACK
ROOF CONSOLE
(ROOF CONSOLE)
SWITCH PACK – DRIVER REAR DOOR
RD1 / 5-WAY JAE IL-AG5 / GREEN
DOOR TRIM PANEL
SWITCH PACK – PASSENGER DOOR
PD1 / 5-WAY JAE IL-AG5 / GREEN
DOOR TRIM PANEL
SWITCH PACK – PASSENGER REAR DOOR
RP1 / 5-WAY JAE IL-AG5 / GREEN
DOOR TRIM PANEL
WINDOW LIFT MOTOR – DRIVER
DD16 / 2-WAY ECONOSEAL III LC / BLACK
DOOR CASING / TRIM PANEL
WINDOW LIFT MOTOR – DRIVER REAR
RD16 / 2-WAY ECONOSEAL III LC / BLACK
DOOR CASING / TRIM PANEL
WINDOW LIFT MOTOR – PASSENGER
PD16 / 2-WAY ECONOSEAL III LC / BLACK
DOOR CASING / TRIM PANEL
WINDOW LIFT MOTOR – PASSENGER REAR
RP16 / 2-WAY ECONOSEAL III LC / BLACK
DOOR CASING / TRIM PANEL
WINDOW LIFT SWITCH
DD1 / 26-WAY AMP MICRO QUAD LOCK / YELLOW
DOOR TRIM PANEL
(DRIVER DOOR SWITCH PACK)
HARNESS-TO-HARNESS CONNECTORS
Connector
Type / Color
Location / Access
CA8
20-WAY MULTILOCK 070 / WHITE
DRIVER ‘A’ POST / DOOR HARNESS GAITER
CA10
8-WAY MULTILOCK 070 / YELLOW
DRIVER ‘A’ POST / DOOR HARNESS GAITER
CA11
20-WAY MULTILOCK 070 / WHITE
PASSENGER ‘A’ POST / DOOR HARNESS GAITER
CA12
8-WAY MULTILOCK 070 / YELLOW
PASSENGER ‘A’ POST / DOOR HARNESS GAITER
CA14
6-WAY MULTILOCK 070 / WHITE
DRIVER ‘B/C’ POST / DOOR HARNESS GAITER
CA16
6-WAY MULTILOCK 070 / WHITE
PASSENGER ‘B/C’ POST / DOOR HARNESS GAITER
FC5
54-WAY THROUGH PANEL CONNECTOR / GREY
BELOW DRIVER SIDE AIR VENT / COIN TRAY
FC7
20-WAY MULTILOCK 070 / YELLOW
ABOVE DIMMER MODULE / COIN TRAY
GROUNDS
Ground
Location / Type
BT22L*
EYELET (PAIR) – TRUNK / RH CENTER GROUND STUD (*PREMIUM ICE)
BT24*
EYELET (SINGLE) – TRUNK / RH CENTER GROUND STUD (*STANDARD ICE)
BT34
EYELET (SINGLE) – KEY FOB ANTENNA GROUND / BACKLIGHT / CENTER
CA30L
EYELET (PAIR) – LH ‘A’ POST GROUND SCREW
CA30R
EYELET (PAIR) – LH ‘A’ POST GROUND SCREW
CA33L
EYELET (PAIR) – RH ‘A’ POST GROUND SCREW
CA33R
EYELET (PAIR) – RH ‘A’ POST GROUND SCREW
CA36L
EYELET (PAIR) – LH ‘A’ POST GROUND SCREW
CA36R
EYELET (PAIR) – LH ‘A’ POST GROUND SCREW
CC3R
EYELET (PAIR) – RH FRONT BULKHEAD STUD / CABIN SIDE
FOR CONTROL MODULE PIN OUT INFORMATION, UNFOLD PAGE TO LEFT.
CONTROL MODULE PIN OUT INFORMATION
BODY PROCESSOR MODULE
P
Pin
Description
Active
Inactive
I
FC15-15
IGNITION SWITCHED GROUND
GROUND
B+
I
FC15-33
IGNITION SWITCHED GROUND
GROUND
B+
I
FC15-41
STARTER ENGAGE REQUEST
GROUND (CRANKING)
B+
O
FC15-46
DRIVER DOOR – SLIDING ROOF GLOBAL CLOSE REQUEST
GROUND (MOMENTARY)
B+
O
FC15-47
CENTRAL LOCKING SWITCH – SLIDING ROOF GLOBAL OPEN REQUEST
GROUND (MOMENTARY)
B+
I
FC15-63
CENTRAL LOCKING REQUEST
GROUND (MOMENTARY)
B+
I
FC15-80
BATTERY SUPPLY VOLTAGE
B+
B+
S
FC15-84
SCP NETWORK
2 – 1600 Hz
S
FC15-85
SCP NETWORK
2 – 1600 Hz
I
FC15-89
REAR WINDOW INHIBIT REQUEST
GROUND
B+
DRIVER DOOR CONTROL MODULE
P
Pin
Description
Active
Inactive
I
DD10-1
BATTERY POWER SUPPLY
B+
B+
O
DD10-7
WINDOW LIFT MOTOR DOWN SUPPLY
B+
GROUND
I
DD10-8
LOGIC GROUND
GROUND
GROUND
S
DD10-9
SCP NETWORK
2 – 1600 Hz
I
DD10-10
DRIVER DOOR SWITCH PACK DRIVER WINDOW DOWN REQUEST
GROUND (MOMENTARY)
B+
O
DD10-15
DRIVER DOOR WINDOW LIFT MOTOR UP SUPPLY
B+
GROUND
S
DD10-16
SCP NETWORK
2 – 1600 Hz
I
DD10-17
POWER GROUND
GROUND
GROUND
I
DD10-18
DRIVER DOOR SWITCH PACK DRIVER WINDOW UP REQUEST
GROUND (MOMENTARY)
GROUND
I
DD10-19
DRIVER DOOR SWITCH PACK PASSENGER WINDOW UP REQUEST
GROUND (MOMENTARY)
GROUND
I
DD11-4
DRIVER DOOR LOCK BARREL UNLOCK REQUEST
B+ (MOMENTARY)
GROUND
I
DD11-6
DRIVER DOOR SWITCH PACK PASSENGER REAR WINDOW UP REQUEST
GROUND (MOMENTARY)
GROUND
I
DD11-7
DRIVER DOOR SWITCH PACK PASSENGER WINDOW DOWN REQUEST
B+ (MOMENTARY)
GROUND
I
DD11-12
DRIVER DOOR LOCK BARREL LOCK REQUEST
B+ (MOMENTARY)
GROUND
I
DD11-15
DRIVER DOOR SWITCH PACK DRIVER REAR WINDOW DOWN REQUEST
GROUND (MOMENTARY)
B+
I
DD11-21
DRIVER DOOR SWITCH PACK PASSENGER REAR WINDOW DOWN REQUEST
B+ (MOMENTARY)
GROUND
I
DD11-22
DRIVER DOOR SWITCH PACK DRIVER REAR WINDOW UP REQUEST
GROUND (MOMENTARY)
GROUND
DRIVER REAR DOOR CONTROL MODULE
P
Pin
Description
Active
Inactive
I
RD10-1
BATTERY POWER SUPPLY
B+
B+
O
RD10-7
DRIVER REAR WINDOW LIFT MOTOR DOWN SUPPLY
B+
GROUND
I
RD10-8
LOGIC GROUND
GROUND
GROUND
S
RD10-9
SCP NETWORK
2 – 1600 Hz
O
RD10-15
DRIVER REAR WINDOW LIFT MOTOR UP SUPPLY
B+
GROUND
S
RD10-16
SCP NETWORK
2 – 1600 Hz
I
RD10-17
POWER GROUND
GROUND
GROUND
I
RD10-19
MODULE IDENTIFICATION
GROUND
GROUND
I
RD11-6
DRIVER REAR DOOR SWITCH PACK WINDOW UP REQUEST
GROUND (MOMENTARY)
GROUND
I
RD11-7
MODULE IDENTIFICATION
GROUND
GROUND
I
RD11-21
DRIVER REAR DOOR SWITCH PACK WINDOW DOWN REQUEST
B+ (MOMENTARY)
GROUND
PASSENGER DOOR CONTROL MODULE
P
Pin
Description
Active
Inactive
I
PD10-1
BATTERY POWER SUPPLY
B+
B+
O
PD10-7
PASSENGER WINDOW LIFT MOTOR DOWN SUPPLY
B+
GROUND
I
PD10-8
LOGIC GROUND
GROUND
GROUND
S
PD10-9
SCP NETWORK
2 – 1600 Hz
O
PD10-15
PASSENGER WINDOW LIFT MOTOR UP SUPPLY
B+
GROUND
S
PD10-16
SCP NETWORK
2 – 1600 Hz
I
PD10-17
POWER GROUND
GROUND
GROUND
I
PD11-6
PASSENGER DOOR SWITCH PACK WINDOW UP REQUEST
GROUND (MOMENTARY)
GROUND
I
PD11-21
PASSENGER DOOR SWITCH PACK WINDOW DOWN REQUEST
B+ (MOMENTARY)
GROUND
PASSENGER REAR DOOR CONTROL MODULE
P
Pin
Description
Active
Inactive
I
RP10-1
BATTERY POWER SUPPLY
B+
B+
O
RP10-7
PASSENGER REAR WINDOW LIFT MOTOR DOWN SUPPLY
B+
GROUND
I
RP10-8
LOGIC GROUND
GROUND
GROUND
S
RP10-9
SCP NETWORK
2 – 1600 Hz
O
RP10-15
PASSENGER REAR WINDOW LIFT MOTOR UP SUPPLY
B+
GROUND
S
RP10-16
SCP NETWORK
2 – 1600 Hz
I
RP10-17
POWER GROUND
GROUND
GROUND
I
RP11-6
PASSENGER REAR DOOR SWITCH PACK WINDOW UP REQUEST
GROUND (MOMENTARY)
GROUND
I
RP11-21
PASSENGER REAR DOOR SWITCH PACK WINDOW DOWN REQUEST
B+ (MOMENTARY)
GROUND
SECURITY AND LOCKING CONTROL MODULE
P
Pin
Description
Active
Inactive
S
BT1-8
SCP NETWORK
2 – 1600 Hz
I
BT1-13
LOGIC GROUND
GROUND
GROUND
I
BT1-14
LOGIC GROUND
GROUND
GROUND
I
BT1-15
BATTERY POWER SUPPLY
B+
B+
S
BT1-16
SCP NETWORK
2 – 1600 Hz
I
BT6-1
KEY FOB ANTENNA
I
BT6-2
KEY FOB ANTENNA SHIELD
GROUND
GROUND
SLIDING ROOF CONTROL MODULE
P
Pin
Description
Active
Inactive
I
CA64-1
BATTERY SUPPLY
B+
B+
I
CA64-2
CENTRAL LOCKING SWITCH – SLIDING ROOF GLOBAL CLOSE REQUEST
GROUND (MOMENTARY)
B+
I
CA64-3
GROUND SUPPLY
GROUND (MOMENTARY)
GROUND
I
CA64-4
DRIVER DOOR – SLIDING ROOF GLOBAL CLOSE REQUEST
GROUND
B+
I
CA64-5
SLIDING ROOF SWITCH OPEN REQUEST
GROUND (MOMENTARY)
B+
I
CA64-6
SLIDING ROOF SWITCH CLOSE REQUEST
GROUND (MOMENTARY)
B+
O
SR2-1
SLIDING ROOF MOTOR SUPPLY
B+
GROUND
O
SR2-3
SLIDING ROOF MOTOR SUPPLY
B+
GROUND
NOTE: Refer to the Appendix at the rear of this book for CAN and SCP Network messages.
The following abbreviations are used to represent values for Control Module Pin-Out data
I
Input
D
Serial and Encoded Data
B+
Battery Voltage
kHz
Frequency x 1000
O
Output
C
CAN (Network)
V
Voltage (DC)
ms
Milliseconds
SG
Signal Ground
S
SCP Network
Hz
Frequency
mV
Millivolts
CAUTION: The information on this data page is furnished to aid the user in understanding circuit operation.
THIS INFORMATION SHOULD BE USED FOR
REFERENCE ONLY.
NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all
components connected and fitted.
“Active” means a load is applied or a switch is ON; “Inactive” means a load is not applied or a switch is OFF.
Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, grounds, control
modules and control module pins.
DATE OF ISSUE:
October 1999
Fig. 16.1
COMPONENTS
Component
Connector / Type / Color
Location / Access
ANTENNA MOTOR
BT19 / 6-WAY YAZAKI TYPE C / WHITE
ANTENNA MOTOR ASSEMBLY / BATTERY COVER
CD AUTO-CHANGER
IC5 / 8-WAY ALPINE / BLACK
TRUNK LH SIDE / TRUNK CARPET
INSTRUMENT PACK
FC24 / 26-WAY AMP MICRO QUAD LOCK / BLACK
FASCIA
FC25 / 26-WAY AMP MICRO QUAD LOCK / YELLOW
RADIO / CASSETTE HEAD UNIT
CA3 / COAXIAL CONNECTOR
CENTER CONSOLE
IC10 / 20-WAY MULTILOCK 070 / WHITE
IC11 / 26-WAY AMP MICRO QUAD LOCK / YELLOW
IC19 / 8-WAY ALPINE / BLACK
RADIO ANTENNA
CA7 / COAXIAL CONNECTOR
ANTENNA MOTOR ASSEMBLY / BATTERY COVER
RADIO CONTROL SWITCHES (STEERING WHEEL)
SW4 / 3-WAY EPC / BLACK
STEERING WHEEL
RADIO TELEPHONE CONNECTOR
RT2 / 10-WAY MULTILOCK 070 / WHITE
BELOW CENTER CONSOLE GLOVE BOX
SPEAKER, ‘A’ POST TWEETER – LH
CA56 / 2-WAY MULTILOCK 040 / BLACK
LH ‘A’ POST / UPPER ‘A’ POST TRIM
SPEAKER, ‘A’ POST TWEETER – RH
CA54 / 2-WAY MULTILOCK 040 / BLACK
RH ‘A’ POST / UPPER ‘A’ POST TRIM
SPEAKER, REAR DOOR MID-BASS – DRIVER SIDE
RD6 / 2-WAY GROTE & HARTMAN MDK / BLACK
DOOR CASING / TRIM PANEL
SPEAKER, REAR DOOR MID-BASS – PASSENGER SIDE
RP6 / 2-WAY GROTE & HARTMAN MDK / BLACK
DOOR CASING / TRIM PANEL
SPEAKER, REAR DOOR TWEETER – DRIVER SIDE
RD5 / 2-WAY GROTE & HARTMAN MDK / BLACK
DOOR CASING / TRIM PANEL
SPEAKER, REAR DOOR TWEETER – PASSENGER SIDE
RP5 / 2-WAY GROTE & HARTMAN MDK / BLACK
DOOR CASING / TRIM PANEL
SPEAKER, FRONT DOOR MID-BASS – DRIVER SIDE
DD6 / 2-WAY GROTE & HARTMAN MDK / BLACK
DOOR CASING / TRIM PANEL
SPEAKER, FRONT DOOR MID-BASS – PASSENGER SIDE
PD6 / 2-WAY GROTE & HARTMAN MDK / BLACK
DOOR CASING / TRIM PANEL
SPEAKER, FRONT DOOR TWEETER – DRIVER SIDE
DD5 / 2-WAY GROTE & HARTMAN MDK / BLACK
DOOR CASING / TRIM PANEL
SPEAKER, FRONT DOOR TWEETER – PASSENGER SIDE
PD5 / 2-WAY GROTE & HARTMAN MDK / BLACK
DOOR CASING / TRIM PANEL
HARNESS-TO-HARNESS CONNECTORS
Connector
Type / Color
Location / Access
BT4
54-WAY THROUGH PANEL / GREY
BELOW PARCEL SHELF / TRUNK / REAR BULKHEAD / RH SIDE
CA10
8-WAY MULTILOCK 070 / YELLOW
DRIVER ‘A’ POST / DOOR HARNESS GAITER
CA12
8-WAY MULTILOCK 070 / YELLOW
PASSENGER ‘A’ POST / DOOR HARNESS GAITER
CA14
6-WAY MULTILOCK 070 / WHITE
DRIVER ‘B/C’ POST / DOOR HARNESS GAITER
CA16
6-WAY MULTILOCK 070 / WHITE
PASSENGER ‘B/C’ POST / DOOR HARNESS GAITER
FC5
54-WAY THROUGH PANEL CONNECTOR / GREY
BELOW DRIVER SIDE AIR VENT / COIN TRAY
IC1
14-WAY MULTILOCK 070 / WHITE
LH HEELBOARD
IC3
12-WAY MULTILOCK 070 / WHITE
LH HEELBOARD
SC3
12-WAY MULTILOCK 070 / GREY
ADJACENT TO STEERING COLUMN MOTOR
GROUNDS
Ground
Location / Type
BT28L
EYELET (PAIR) – TRUNK / RH CENTER GROUND STUD
FC17R
EYELET (PAIR) – EMS BULKHEAD GROUND STUD
IC8
EYELET (SINGLE) – RADIO GROUND STUD / TRANSMISSION TUNNEL / CENTER
FOR CONTROL MODULE PIN OUT INFORMATION, UNFOLD PAGE TO LEFT.
CONTROL MODULE PIN OUT INFORMATION
INSTRUMENT PACK
P
Pin
Description
Active
Inactive
C
FC24-11
CAN NETWORK
15 – 1500 Hz
C
FC24-24
CAN NETWORK
15 – 1500 Hz
O
FC25-20
VEHICLE SPEED
22 Hz @ 10 MPH (16 KM/H); 44 Hz @ 20 MPH (32 KM/H) @ B+
RADIO / CASSETTE HEAD UNIT
P
Pin
Description
Active
Inactive
I
IC11-1
VEHICLE SPEED
22 Hz @ 10 MPH (16 KM/H); 44 Hz @ 20 MPH (32 KM/H) @ B+
I
IC11-2
STEERING WHEEL AUDIO CONTROLS
0 V = MODE, 1.2 V = SEEK, 2.4 V = VOLUME ‘+’, 3.7 V = VOLUME ‘-’
5V
O
IC11-18
ANTENNA UP
B+
GROUND
NOTE: Refer to the Appendix at the rear of this book for CAN and SCP Network messages.
|