Nissan Titan A60. Manual - part 707

MA-8

< PERIODIC MAINTENANCE >

GENERAL MAINTENANCE

UNDER THE HOOD AND VEHICLE
The maintenance items listed here should be checked periodically (e.g. each time you check the engine oil or refuel).

Steering wheel

Check that it has the specified play. Be sure to check for changes in the steering
condition, such as excessive play, hard steering or strange noises. Free play:
Less than 35 mm (1.38 in.)

MA-44, "STEERING

GEAR AND LINKAGE :

Checking Steering Gear

and Linkage"

Seat belts

Check that all parts of the seat belt system (e.g. buckles, anchors, adjusters and
retractors) operate properly and smoothly and are installed securely. Check the
belt webbing for cuts, fraying, wear or damage.

Seat Belts, Buckles, Re-

tractors, Anchors and

Adjusters"

Item

Reference page

Item

Reference page

Windshield washer
fluid

Check that there is adequate fluid in the tank.

—

Engine coolant level

Check the coolant level when the engine is cold.

MA-24, "FOR MEXICO :

Engine Coolant Mixture

Ratio"

Brake fluid level

Make sure that the brake fluid level is between the “MAX” and “MIN” lines on the
reservoir.

MA-43, "BRAKE FLUID

LEVEL AND LEAKS :
Checking Brake Fluid

Level and Leaks"

Battery

Check the fluid level in each cell. It should be between the “MAX” and “MIN” lines.
Vehicles operated in high temperatures or under severe conditions require fre-
quent checks of the battery fluid level.

—

Engine oil level

Check the level on the dipstick after parking the vehicle on a level spot and turn-
ing off the engine.

MA-22, "FOR MEXICO :

Fluids and Lubricants"

PERIODIC MAINTENANCE

MA-9

< PERIODIC MAINTENANCE >

PERIODIC MAINTENANCE

FOR NORTH AMERICA
FOR NORTH AMERICA : Introduction of Periodic Maintenance

INFOID:0000000006158417

Two different maintenance schedules are provided, and should be used, depending upon the conditions in

which the vehicle is mainly operated. After 60,000 miles (96,000 km) or 48 months, continue the periodic

maintenance at the same mileage or time intervals, whichever comes first.

Maintenance for off-road driving (4WD only)

After driving the vehicle off-road through sand, mud, or water; more frequent maintenance may be required for

the following items:

Brake pads and rotors
Brake lines and hoses
Differential, tansfer gear oil and automatic transmission fluid
Steering linkage
Drive shafts
Engine air cleaner filter

FOR NORTH AMERICA : Schedule 1

INFOID:0000000006158418

EMISSION CONTROL SYSTEM MAINTENANCE

Abbreviations: R = Replace. I = Inspect. Correct or replace if necessary. [ ]: At the mileage intervals only

Schedule 1

Follow Periodic Maintenance Schedule 1 if your driving habits frequently includes
one or more of the following driving conditions:
• Repeated short trips of less than 5 miles (8 km).
• Repeated short trips of less than 10 miles (16 km) with outside temperatures re-

maining below freezing.

• Operating in hot weather in stop-and-go “rush hour” traffic.
• Extensive idling and/or low speed driving for long distances, such as police, taxi

or door-to-door delivery use.

• Driving in dusty conditions.
• Driving on rough, muddy, or salt spread roads.
• Towing a trailer or using a camper or car-top carrier.

Emission Control Sys-
tem Maintenance

MA-9

Chassis and Body
Maintenance

MA-9

Schedule 2

Follow Periodic Maintenance Schedule 2 if none of the driving conditions shown
in Schedule 1 apply to the driving habits.

Emission Control Sys-
tem Maintenance

MA-12

Chassis and Body
Maintenance

MA-12

MAINTENANCE OPERATION

MAINTENANCE INTERVAL

Reference

Section -

Page or -

Content Title

Perform at number of miles,
kilometers or months, which-
ever comes first.

Miles x 1,000

(km x 1,000)

Months

3.75

(6)

7.50

(12)

11.25

(18)

(24)

18.75

(30)

22.5

(36)

26.25

(42)

(48)

Drive belts

NOTE (1)

EM-13

Air cleaner filter

NOTE (2)

[R]

MA-29

EVAP vapor lines

MA-33

Fuel lines

FL-5

Fuel filter

NOTE (3)

MA-29

Engine coolant*

NOTE (4)

CO-10

Engine oil

LU-9

Engine oil filter

MA-30

Spark plugs (Iridium -tipped
type)

Replace every 105,000 miles (168,000 km).

MA-31

Intake and exhaust valve
clearance*

NOTE (5)

EM-114

MA-10

< PERIODIC MAINTENANCE >

PERIODIC MAINTENANCE

(1) After 60,000 miles (96,000 km) or 48 months, inspect every 15,000 miles (24,000 km) or 12 months. Replace the drive belts if found
damaged or if the auto belt tensioner reading reaches the maximum limit.
(2) If operating mainly in dusty conditions, more frequent maintenance may be required.
(3) Maintenance-free item. For service procedures, refer to the FL section.
(4) First replacement interval is 105,000 miles (168,000 km) or 84 months. After first replacement, replace every 75,000 miles (120,000
km) or 60 months. Use only Genuine NISSAN Long Life Antifreeze / Coolant (blue) or equivalent with the proper mixure ratio of 50%
anti-freeze and 50% demineralized or distilled water. Mixing any other type of coolant or the use of non-distilled waterwill reduce the life
expectency of the factory-fill coolant.
(5) Periodic maintenance is not required. However, if valve noise increases, inspect valve clearance.
* Maintenance items and intervals with “*” are recommended by NISSAN for reliable vehicle operation. The owner need not perform
such maintenance in order to maintain the emission warranty or manufacturer recall liability. Other maintenance items and intervals are
required.

CHASSIS AND BODY MAINTENANCE

Abbreviations: R = Replace. I = Inspect. Correct or replace if necessary.

MAINTENANCE OPERATION

MAINTENANCE INTERVAL

Reference

Section -

Page or -

Content Title

Perform at number of miles,
kilometers or months, which-
ever comes first.

Miles x 1,000

(km x 1,000)

Months

33.75

(54)

37.5

(60)

41.25

(66)

(72)

48.75

(78)

52.5

(84)

56.25

(90)

(96)

Drive belts

NOTE (1)

EM-13

Air cleaner filter

NOTE (2)

[R]

MA-29

EVAP vapor lines

MA-33

Fuel lines

FL-5

Fuel filter

NOTE (3)

MA-29

Engine coolant*

NOTE (4)

CO-11

Engine oil

LU-9

Engine oil filter

MA-30

Spark plugs ( Iridium-tipped
type)

Replace every 105,000 miles (168,000 km).

MA-31

Intake and exhaust valve
clearance*

NOTE (5)

EM-114

MAINTENANCE OPERATION

MAINTENANCE INTERVAL

Reference

Section

- Page

- Content

Title

Perform at number of miles, kilometers or
months, whichever comes first.

Miles x

1,000
(km x

1,000)

Months

3.75

(6)

7.5

(12)

11.25

(18)

(24)

18.75

(30)

22.5

(36)

26.25

(42)

(48)

Brake fluid

MA-43

Brake lines and cables

MA-43

Brake pads and rotors

MA-43

Automatic transmission fluid, transfer fluid and
differential gear oil

NOTE (1)

Steering gear and linkage, axle and suspension
parts

MA-44

MA-45

Tire rotation

NOTE (2)

WT-46,

"Adjust-

ment"

Drive shaft boots and propeller shaft (4WD)

MA-39

PERIODIC MAINTENANCE

MA-11

< PERIODIC MAINTENANCE >

(1) If towing a trailer, or using a camper or car-top carrier, or driving on rough or muddy roads, change (not just inspect) oil/fluid at every
30,000 miles (48,000 km) or 24 months. Using automatic transmission fluid other than Genuine NISSAN Matic S ATF or Matic J

Exhaust system

In-cabin microfilter

MAINTENANCE OPERATION

MAINTENANCE INTERVAL