Mitsubishi Montero (1991+). Manual - part 303

 

  Index      Mitsubishi     Mitsubishi Montero - service repair manual 1991 year

 

Search            

 

 

 

 

 

 

 

 

 

Content   ..  301  302  303  304   ..

 

 

Mitsubishi Montero (1991+). Manual - part 303

 

 

                  cracked or broken            manifold, See ENGINES



         ENGINE PERFORMANCE

         CARBURETOR TROUBLE SHOOTING:

NOTE:    This is GENERAL information.  This article is not intended

         to be specific to any unique situation or individual vehicle

         configuration.  The purpose of this Trouble Shooting

         information is to provide a list of common causes to

         problem symptoms.  For model-specific Trouble Shooting,

         refer to SUBJECT, DIAGNOSTIC, or TESTING articles available

         in the section(s) you are accessing.

BASIC COLD START SYMPTOMS TROUBLE SHOOTING CHART



CONDITION          POSSIBLE CAUSE                 CORRECTION



Engine Won’t       Choke not closing              Check choke

Start                                             operation, see

                                                  FUEL SYSTEMS

                   Choke linkage bent             Check linkage, see

                                                  FUEL SYSTEM



Engine Starts,     Choke vacuum kick setting      Check setting and

Then Dies          too wide                       adjust see, FUEL

                                                  SYSTEMS

                   Fast idle RPM too low          Reset RPM to specif-

                                                  ication, see TUNE-UP

                   Fast idle cam index            Reset fast idle cam

                   incorrect                      index, see FUEL

                                                  SYSTEMS

                   Vacuum leak                    Inspect vacuum

                                                  system for leaks

                   Low fuel pump outlet           Repair or replace

                                                  pump, see FUEL

                                                  SYSTEMS

                  Low carburetor fuel level       Check float setting

                                                  see FUEL SYSTEM



Engine Quits       Choke vacuum kick setting      Reset vacuum kick

Under Load         incorrect                      setting,see FUEL

                                                  SYSTEMS

                   Fast idle cam index            Reset fast idle cam

                   incorrect                      index, see FUEL

                                                  SYSTEM

                   Incorrect hot fast idle        Reset fast idle RPM,

                   speed RPM                      see TUNE-UP



Engine Starts,     Choke vacuum kick set too      Reset vacuum kick,

Runs Up,Then       narrow                         see FUEL SYSTEMS

Idles, Slowly

With Black Smoke   Fast idle cam index            Reset fast idle cam

                   incorrect                      index, see FUEL

                                                  SYSTEMS

                   Hot fast idle RPM too low      Reset fast idle RPM,

                                                  see TUNE-UP



BASIC HOT START SYMPTOMS TROUBLE SHOOTING CHART



CONDITION          POSSIBLE CAUSE                 CORRECTION



Engine Won’t       Engine flooded                 Allow fuel to

Start                                             evaporate



BASIC COLD ENGINE DRIVEABILITY SYMPTOMS TROUBLE SHOOTING CHART



CONDITION          POSSIBLE CAUSE                 CORRECTION



Engine Stalls in   Choke vacuum kick setting      Reset choke vacuum

Gear               incorrect                      kick, see FUEL

                                                  SYSTEMS

                   Fast idle RPM incorrect        Reset fast idle RPM,

                                                  see TUNE-UP

                   Fast idle cam index            Reset fast idle cam

                   incorrect                      see FUEL SYSTEMS



Acceleration Sag   Defective choke control        Replace choke

or Stall           switch                         control switch

                   Choke vacuum kick setting      Reset choke vacuum

                   incorrect                      kick see, FUEL

                                                  SYSTEMS

                   Float level incorrect          Adjust float level,

                   (too low)                      FUEL SYSTEMS

                   Accelerator pump defective     Repair or replace

                                                  pump see FUEL

                                                  SYSTEMS

                   Secondary throttles not        Inspect lockout

                   closed                         adjustment,see FUEL

                                                  SYSTEMS



Sag or Stall       Defective choke control        Replace choke

After Warmup       switch                         control switch, see

                                                  FUEL SYSTEMS

                   Defective accelerator pump     Replace pump, see

                                                  FUEL SYSTEMS

                   Float level incorrect          Adjust float level,

                   (too low)                      see FUEL SYSTEMS



Backfiring &       Plugged heat crossover         Remove restriction

Black Smoke        system



BASIC WARM ENGINE DRIVEABILITY SYMPTOMS TROUBLE SHOOTING CHART



CONDITION          POSSIBLE CAUSE                 CORRECTION



Hesitation With    Vacuum leak                    Inspect vacuum lines

Small Amount of

Gas Pedal Movement

                   Accelerator pump weak or       Replace pump, see

                   inoperable                     FUEL SYSTEMS

                   Float level setting too low    Reset float level,

                                                  see,FUEL SYSTEMS

                   Metering rods sticking or      Inspect and/or

                   binding                        replace rods, see

                                                  FUEL SYSTEMS

                   Carburetor idle or transfer    Inspect system and

                   system plugged                 remove restriction

                   Frozen or binding heated air   Inspect heated air

                   inlet                          door for binding



Hesitation With    Defective accelerator pump     Replace pump, see

Heavy Gas Pedal                                   FUEL SYSTEMS

Movement

                   Metering rod carrier           Remove restriction

                   sticking or binding

                   Large vacuum leak              Inspect vacuum

                                                  system and repair

                                                  leak

                   Float level setting too        Reset float level,

                   low                            see FUEL SYSTEMS

                   Defective fuel pump, lines     Inspect pump, lines

                   or filter                      and filter

                   Air door setting incorrect     Adjust air door

                                                  setting, see FUEL



         DIESEL ENGINE TROUBLE SHOOTING

NOTE:    This is GENERAL information.  This article is not intended

         to be specific to any unique situation or individual vehicle

         configuration.  The purpose of this Trouble Shooting

         information is to provide a list of common causes to

         problem symptoms.  For model-specific Trouble Shooting,

         refer to SUBJECT, DIAGNOSTIC, or TESTING articles available

         in the section(s) you are accessing.

NOTE:    Diesel engines mechanical diagnosis is the same as gasoline

         engines for items such as noisy valves, bearings, pistons,

         etc. The following trouble shooting covers only items

         pertaining to diesel engines.

BASIC DIESEL ENGINE TROUBLE SHOOTING CHART



CONDITION         POSSIBLE CAUSE               CORRECTION



Engine Won’t      Bad battery connections      Check connections

Crank             or dead batteries            and/or replace

                                               batteries

                  Bad starter connections      Check connections

                  or bad starter               and/or replace

                                               batteries



Engine Cranks     Bad battery connections      Check connections

Slowly, Won’t     or dead batteries            and/or replace

Start                                          batteries

                  Engine oil too heavy         Replace engine oil



Engine Cranks     Glow plugs not functioning   Check glow plug system,

Normally, But                                  see FUEL SYSTEMS

Will Not Start    Glow plug control not        Check controller, see

                  functioning                  FUEL SYSTEMS

                  Fuel not injected into       Check fuel injectors,

                  cylinders                    see FUEL SYSTEMS

                  No fuel to injection pump    Check fuel delivery

                                               system

                  Fuel filter blocked          Replace fuel filter

                  Fuel tank filter blocked     Replace fuel tank

                                               filter

                  Fuel pump not operating      Check pump operation

                                               and/or replace pump

                  Fuel return system blocked   Inspect system and

                                               remove restriction

                  No voltage to fuel solenoid  Check solenoid and

                                               connections

                  Incorrect or contaminated    Replace fuel

                  fuel

                  Incorrect injection pump     Re-adjust pump timing,

                  timing                       see FUEL SYSTEMS

                  Low compression              Check valves, pistons,

                                               rings, see ENGINES

                  Injection pump malfunction   Inspect and/or replace

                                               injection pump



Engine Starts,    Incorrect slow idle          Reset idle adjustment,

Won’t Idle        adjustment                   see TUNE-UP

                  Fast idle solenoid           Check solenoid and

                  malfunctioning               connections

                  Fuel return system blocked   Check system and remove

                                               restrictions

                  Glow plugs go off too soon   See glow plug diagnosis

                                               in FUEL SYSTEMS

                  Injection pump timing        Reset pump timing, see

                  incorrect                    FUEL SYSTEMS

                  No fuel to injection pump    Check fuel delivery

                                               system

                  Incorrect or contaminated    Replace fuel

                  fuel

                  Low compression              Check valves, piston,

                                               rings, see ENGINES

                  Injection pump malfunction   Replace injection pump,

                                               see FUEL SYSTEMS

                  Fuel solenoid closes in RUN  Check solenoid and

                  position                     connections



Engines Starts/   Incorrect slow idle          Reset slow idle, see

Idles Rough W/out adjustment                   TUNE-UP

Smoke or Noise    Injection line fuel leaks    Check lines and

                                               connections

                  Fuel return system blocked   Check lines and

                                               connections

 

 

 

 

 

 

 

Content   ..  301  302  303  304   ..