Content .. 180 181 182 183 ..

Mitsubishi Montero (1991+). Manual - part 182

1987-91 ...................................... 2.3 Qts. (2.2L)

1992-95 ...................................... 2.4 Qts. (2.3L)

Service Labor Times

Application Hours

30,000 (60,000) 50,000

Application Mile Service Mile Service

2.6L 4-Cylinder

Automatic Transmission .... 7.9 (8.9) ................. 2.6

Manual Transmission ....... 6.9 (7.9) ................. 2.6

3.0L V6

Automatic Transmission .... 6.1 (10.6) ................ 2.6

Manual Transmission ....... 5.1 (9.6) ................. 2.6

LUBRICATION SPECIFICATIONS TABLE

Application Fluid Specifications

Brake & Clutch Fluid ........................... DOT 3 Or DOT 4

Engine Coolant ............. Ethylene-Glycol Antifreeze Coolant

Engine Oil (1)

Minimum Temperature

Greater Than 32

F (0

C) ..... SAE 20W-40 Or 20W-50 API SG/CD

Greater Than -10

F (-23

C) .. SAE 10W-30 Or 10W-40 API SG/CD

Maximum Temperature

Less Than 60

F (16

C) ......... SAE 5W-30 Or 5W-40 API SG/CD

Front Axle & Conventional Rear Axle

Minimum Temperature

Greater Than -10

F (-23

C) ..... SAE 85W-90, 80W-90 API GL-5

Maximum Temperature

Less Than -30

F (-34

C) ................... SAE 75W API GL-5

Power Steering Fluid ........................... Dexron-IIE ATF

Rear Axle (With Limited

Slip Differential) ........... Hypoid Gear Oil (8149630EX) Or

Equivalent

Transmission

Automatic .................................... Dexron-IIE ATF

Manual Transaxle &

Transfer Case (4WD) ........... SAE 75W-85W, 75W-90 API GL-5

(1) - Since temperature ranges for different oil grades overlap,

brief fluctuations in outside temperatures are no cause for

concern.

FLUID CAPACITIES

FLUID CAPACITIES TABLE

Application Quantity

A/C System R-12 Refrigerant

1983-87 .......................................... 24-26 Ozs.

1988-91 ............................................. 32 Ozs.

1992-93 ............................................. 28 Ozs.

A/C System R-134a Refrigerant (1)

1994-95 .......................................... 21-23 Ozs.

Automatic Transmission

1984-86 ................................. ( 2) 7.2 Qts. (6.8L)

1987-93 ..................................... 7.6 Qts. (7.2L)

1994 (3.0L SOHC) ............................ 7.6 Qts. (7.2L)

1994 (3.0L DOHC & 3.5L) ..................... 9.0 Qts. (8.5L)

1995 ........................................ 7.9 Qts. (7.5L)

Cooling System

1983-88 ..................................... 8.5 Qts. (8.0L)

1989-95

2.6L ....................................... 9.7 Qts. (9.2L)

3.0L ...................................... 10.0 Qts. (9.5L)

1994

3.5L ...................................... 10.0 Qts. (9.5L)

Differential

1983-88 ..................................... 1.9 Qts. (1.8L)

1989-93

2.6L ....................................... 1.9 Qts. (1.8L)

3.0L ....................................... 2.7 Qts. (2.6L)

1994

3.0L & 3.5L ................................ 2.7 Qts. (2.6L)

1995

3.0L ....................................... 2.7 Qts. (2.6L)

3.5L ....................................... 3.3 Qts. (3.2L)

Engine Oil

1983-86 ..................................... 6.0 Qts. (5.8L)

1987 ........................................ 5.2 Qts. (5.0L)

1988 ........................................ 5.0 Qts. (4.8L)

1989-91 ..................................... 5.5 Qts. (5.3L)

1992-95 ..................................... 5.2 Qts. (4.9L)

Power Steering ................................ 1.1 Qts. (1.0L)

Fuel Tank

1983-88 .................................... 15.9 Gals. (60L)

1989-90

2.6L 2-Door ............................... 15.9 Gals. (60L)

3.0L 2-Door ............................... 19.9 Gals. (75L)

2.6L & 3.0L 4-Door .......................... 24 Gals. (92L)

1991-95 ...................................... 24 Gals. (92L)

Manual Transmission

1983-91 ..................................... 2.3 Qts. (2.2L)

1992 ........................................ 2.4 Qts. (2.3L)

1993-95 ..................................... 2.6 Qts. (2.5L)

Transfer Case

1983-91 ..................................... 2.3 Qts. (2.2L)

1992-95 ..................................... 2.4 Qts. (2.3L)

(1) - Use of R12 in a R134a system will result in SEVERE DAMAGE.

(2) - 1983 model equipped with manual transmission only.

K - SENSOR RANGE CHARTS

1991 Mitsubishi Montero

1991 ENGINE PERFORMANCE

Sensor Operating Range Charts

Chrysler Motors: Colt, Colt 200, Colt Vista,

Ram-50, Stealth, Summit,

Mitsubishi: Eclipse, Galant, Mirage, Montero,

Pickup, 3000GT

INTRODUCTION

Sensor operating range information can help determine if a

sensor is out of calibration. An out-of-calibration sensor may not set

a trouble code, but it may cause driveability problems.

SENSOR OPERATING RANGE CHARTS

NOTE: Unless stated otherwise in test procedure, perform all

voltage tests using a Digital Volt-Ohmmeter (DVOM) with a

minimum 10-megohm input impedance. For connector and

terminal identification, see L - WIRING DIAGRAMS article in

the ENGINE PERFORMANCE Section.

COOLANT TEMP SENSOR RESISTANCE TABLE (1)

Temperature

F (

C) Ohms

Galant, Montero 3.0L, & Pickup 3.0L

32 (0) ............................. 5900

68 (20) ............................ 2500

104 (40) ........................... 2700

176 (80) ............................ 300

All Others

32 (0) ............................. 5900

68 (20) ............................ 2500

104 (40) ........................... 1100

176 (80) ............................ 300

(1) - Measure resistance across disconnected

sensor terminals.

EGR TEMP SENSOR RESISTANCE TABLE (1) (2)

Temperature

F (

C) Ohms

122 (50) ............................ 60-83

212 (100) .......................... 11-14

(1) - Measure resistance across disconnected

sensor terminals.

(2) - Specifications apply to all models

except Montero.

INTAKE AIR TEMP SENSOR RESISTANCE TABLE (1)

Temperature

F (

C) Ohms

32 (0) ............................... 6000

68 (20) .............................. 2700

176 (80) .............................. 400

(1) - On Stealth and 3000GT, measure resistance

between terminals No. 5 and 6 of airflow

sensor connector. On all other models measure

resistance between terminals No. 4 and 6 of

airflow sensor connector.

MOTOR POSITION SENSOR RESISTANCE TEST TERMINALS TABLE

Application (1) Terminals (2) Terminals

Colt Vista ................ 1-3 ............... 1-2

Colt, Colt 200, & Summit .. 2-3 ............... 3-5

(1) - Measure resistance between terminals of motor

position sensor connector.

(2) - Apply 6 volts between terminals No. 1 and 2 of

idle speed control (ISC) connector. Check

resistance between terminals of motor position

sensor when ISC motor is activated.

MOTOR POSITION SENSOR RESISTANCE TABLE (1)

Condition Ohms

Connector Unplugged ....................... 4000-6000

6 Volts Applied ......... Resistance Changes Smoothly

(1) - See MOTOR POSITION SENSOR RESISTANCE

TEST TERMINALS table for terminal positions.

OXYGEN SENSOR VOLTAGE TABLE (1) (2)

Application Volts

All Models

Lean ................................ 0.1

Rich ................................ 1.0

(1) - Measure between sensor terminal No. 1

and ground or between terminals No. 1 and 2.

(2) - Test at normal operating temperature.

O2 SENSOR HEATING ELEMENT RESISTANCE TABLE ( 1)

Application (2) Temperature:

F (

C) Ohms

Eclipse 2.0L Galant 2.0L, Mirage 1.6L ...... 68 (20) .......... 12

Montero 3.0L, Pickup 3.0L & Ram-50 3.0L .... 68 (20) .......... 20

Stealth & 3000GT 3.0L (3) .................. 68 (20) .......... 20

(1) - Measure between sensor terminals No. 3 and 4.

(2) - Information on other models not available from manufacturer.

(3) - Stealth and 3000GT turbo models have 2 oxygen sensors.

Measure between sensor terminals No. 2 and 4 on rear sensor.

Content .. 180 181 182 183 ..