Dodge Caliber. Manual - part 70

FUSE LOCATIONS & TYPES

SPECIFICATIONS

INTEGRATED POWER MODULE (IPM)

An Integrated Power Module is located in the engine compartment near the air cleaner assembly. This center con-
tains cartridge fuses and mini fuses. A label that identifies each component may be printed on the inside of the
cover.

Cavity

Cartridge Fuse

Mini Fuse

Description

40 Amp Green

Power Top Feed

20 Amp Yellow

AWD ECU Feed

10 Amp Red

CHMSL Brake Switch Feed

10 Amp Red

Ignition Switch Feed

20 Amp Yellow

Trailer Tow

10 Amp Red

IOD Sw/Pwr Mir/Ocm
Steering Cntrl Sdar/Hfm

30 Amp Green

IOD Sense1

30 Amp Green

IOD Sense2

40 Amp Green

Power Seats

20 Amp Yellow

CCN Power Locks

15 Amp Lt Blue

Power Outlet

20 Amp Yellow

Ign Run/Acc Inverter

20 Amp Yellow

Pwr run/Acc Outlet RR

10 Amp Red

IOD CCN/ Interior Lighting

40 Amp Green

RAD Fan Relay Battery Feed

15 Amp Lt. Blue

IGN Run/Acc Cigar Ltr/Sunroof

10 Amp Red

IOD Feed Mod-Wcm

40 Amp Green

ASD Relay Contact PWR Feed

20 Amp Yellow

PWR Amp 1 & Amp 2 Feed

15 Amp Lt. Blue

IOD Feed Radio

10 Amp Red

IOD Feed Intrus Mod/Siren

10 Amp Red

IGN RUN Hvac/Compass Sensor

15 Amp Lt. Blue

ENG ASD Relay Feed 3

25 Amp Natural

PWR Sunroof Feed

10 Amp Red

Heated Mirror

15 Amp Lt. Blue

ENG ASD Relay Feed 2

10 Amp Red

IGN RUN Only ORC Feed

10 Amp Red

IGN RUN ORC/OCM Feed

Hot Car (No Fuse Required)

20 Amp Yellow

Heated Seats

10 Amp Red

Headlamp Washer Relay Control

30 Amp Pink

ENG ASD Control Feed 1

10 Amp Red

ABS MOD/J1962 Conn/PCM

30 Amp Pink

ABS Valve Feed

40 Amp Green

ABS Pump Feed

VEHICLE QUICK REFERENCE

4 - 3

Cavity

Cartridge Fuse

Mini Fuse

Description

30 Amp Pink

Headlamp Washer Control / Smart Glass

25 Amp Natural

110 Inverter

CAUTION: When installing the Integrated Power Module cover, it is important to ensure the cover is prop-
erly positioned and fully latched. Failure to do so may allow water to get into the Integrated Power Module,
and possibly result in an electrical system failure.

CAUTION: When replacing a blown fuse, it is important to use only a fuse having the correct amperage
rating. The use of a fuse with a rating other than indicated may result in a dangerous electrical system
overload. If a properly rated fuse continues to blow, it indicates a problem in the circuit that must be cor-
rected.

4 - 4

VEHICLE QUICK REFERENCE

MAINTENANCE SCHEDULES

DESCRIPTION

MAINTENANCE SCHEDULE

There are three maintenance schedules that show required service for your vehicle.

First is Schedule “B”- ALL ENGINES. It is for vehicles that are operated under the conditions that are listed below
and at the beginning of the schedule.

•

Day or night temperatures are below 32° F (0° C).

•

Stop and go driving.

•

Extensive engine idling.

•

Driving in dusty conditions.

•

Short trips of less than 10 miles (16 km).

•

More than 50% of your driving is at sustained high speeds during hot weather, above 90° F (32° C).

•

Trailer towing.

•

Taxi, police, or delivery service (commercial service).

•

Off-road or desert operation.

•

Heavy Loading

NOTE: If ANY of these apply to you then change your engine oil every 3,000 miles (5 000 km) or 3 months,
whichever comes first and follow schedule “B” of the

(

Maintenance Schedules

(

section of this manual.

NOTE: If ANY of these apply to you then change your coolant every 102,000 miles (170 000 km) or 60
months, whichever comes first and follow schedule “B” of the

(

Maintenance Schedules

(

section of this

manual.

NOTE: Most vehicles are operated under the conditions listed for Schedule

(

- ALL ENGINES.

Second is Schedule “A”. It is for vehicles that are not operated under any of the conditions listed under Schedule

Use the schedule that best describes your driving conditions. Where time and mileage are listed, follow the interval
that occurs first.

Under no circumstances should oil change intervals exceed 6000 miles (10 000 km) or 6 months whichever comes
first.

CAUTION: Failure to perform the required maintenance items may result in damage to the vehicle.

At Each Stop for Fuel

•

Check the engine oil level about 5 minutes after a fully warmed engine is shut off. Checking the oil level while
the vehicle is on level ground will improve the accuracy of the oil level reading. Add oil only when the level is
at or below the ADD or MIN mark.

•

Check the windshield washer solvent and add, if required.

Once a Month

•

Check tire pressure and look for unusual wear or damage.

•

Inspect the battery and clean and tighten the terminals as required.

•

Check the fluid levels of coolant reservoir, brake master cylinder, and transmission and add as needed.

•

Check all lights and all other electrical items for correct operation.

At Each Oil Change

•

Change the engine oil filter.

•

Inspect the exhaust system.

VEHICLE QUICK REFERENCE

4 - 5

•

Inspect the brake hoses.

•

Inspect the CV joints (if equipped) and front suspension components.

•

Check the manual transmission fluid level (if equipped).

•

Check the coolant level, hoses, and clamps.

CAUTION: Do not check the automatic transaxle fluid. It must be check by a trained service technician
every 15,000 miles and if required only the recommended fluid be added. Refer to the section “Fluids, Lubri-
cants And Genuine Parts” for the proper fluid.

SCHEDULE B

Follow schedule “B” if you usually operate your vehicle under one or more of the following conditions.

•

Day or night temperatures are below 32° F (0° C).

•

Stop and go driving.

•

Extensive engine idling.

•

Driving in dusty conditions.

•

Short trips of less than 10 miles (16 km).

•

More than 50% of your driving is at sustained high speeds during hot weather, above 90° F (32° C).

•

Trailer towing.

•

Taxi, police, or delivery service (commercial service).

•

Off-road or desert operation.

•

Heavy Loading

NOTE: If ANY of these apply to you then change your engine oil every 3,000 miles (5 000 km) or 3 months,
whichever comes first and follow schedule “B” of the

(

Maintenance Schedules

(

section of this manual.

NOTE: If ANY of these apply to you then change your coolant every 102,000 miles (170 000 km) or 60
months, whichever comes first and follow schedule “B” of the

(

Maintenance Schedules

(

section of this

manual.

Miles

3,000

6,000

9,000

12,000

15,000

(Kilometers)

(5 000)

(10 000)

(15 000)

(20 000)

(25 000)

Change engine oil and engine oil filter, or at 3 months
whichever comes first.

Rotate tires.

Check spare tire for proper pressure and correct
stowage.

Inspect engine air cleaner filter, replace if
necessary.

Inspect and replace make-up air filter, if required.

Miles

18,000

21,000

24,000

27,000

30,000

(Kilometers)

(30 000)

(35 000)

(40 000)

(45 000)

(50 000)

Change engine oil and engine oil filter, or at 3 months
whichever comes first.

Rotate tires.

Check spare tire for proper pressure and correct
stowage.

Inspect brake linings.

Replace air cleaner filter.

Replace spark plugs.

4 - 6

VEHICLE QUICK REFERENCE

Content .. 68 69 70 71 ..