Dodge Caliber. Manual - part 6

 

  Index      Dodge     Dodge Caliber - service repair manual 2007 year

 

Search            

 

 

 

 

 

 

 

 

 

Content   ..  4  5  6  7   ..

 

 

Dodge Caliber. Manual - part 6

 

 

Miles

105,000

108,000

111,000

114,000

117,000

120,000

(Kilometers)

(175
000)

(180
000)

(185
000)

(190
000)

(195
000)

(200
000)

Inspect PCV valve, replace as necessary.**

X

Inspect auto tension drive belt and replace, if
required.

X

X

Flush and replace engine coolant, if not replaced
at 102,000 miles (170 000 km).

X

** This maintenance is recommended by the manufacturer to the owner, but not required to maintain the emissions
warranty.

SCHEDULE A

Miles

6,000

12,000

18,000

24,000

30,000

(Kilometers)

(10 000)

(20 000)

(30 000)

(40 000)

(50 000)

[Months]

[6]

[12]

[18]

[24]

[30]

Change engine oil and engine oil filter.

X

X

X

X

X

Rotate tires.

X

X

X

X

X

Check spare tire for proper pressure and correct
stowage.

X

X

X

X

X

Inspect brake linings.

X

Replace engine air cleaner filter.

X

Replace make-up air filter.

X

Replace spark plugs.

X

Miles

36,000

42,000

48,000

54000

60,000

66,000

(Kilometers)

(60 000)

(70 000)

(80

000)

(90

000)

(100
000)

(110

000)

[Months]

[36]

[42]

[48]

[54]

[60]

[66]

Change engine oil and engine oil filter.

X

X

X

X

X

X

Rotate tires.

X

X

X

X

X

X

Check spare tire for proper pressure and correct
stowage.

X

X

X

X

X

X

Flush and replace engine coolant at 60 months,
if not replaced at 102,000 miles (170 000 km).

X

Inspect brake linings.

X

X

Replace engine air cleaner filter.

X

Replace make-up air filter.

X

Replace spark plugs.

X

Inspect PCV valve, replace as necessary.**

X

Inspect auto tension drive belt and replace, if
required.

X

PM

LUBRICATION & MAINTENANCE

0 - 15

Miles

72,000

78,000

84,000

90,000

96,000

(Kilometers)

(120
000)

(130 000)

(140
000)

(150
000)

(160
000)

[Months]

[72]

[78]

[84]

[90]

[96]

Change engine oil and engine oil filter.

X

X

X

X

X

Rotate tires.

X

X

X

X

X

Check spare tire for proper pressure and correct
stowage.

X

X

X

X

X

Inspect brake linings.

X

X

Inspect engine air cleaner filter, replace if
necessary.

X

Replace engine air cleaner filter.

X

Replace make-up air filter.

X

Replace spark plugs.

X

Inspect PCV valve, replace as necessary.**

X

Inspect auto tension drive belt and replace, if required.

X

Miles

102,000

108,000

114,000

120,000

(Kilometers)

(170 000)

(180 000)

(190 000)

(200 000)

[Months]

[102]

[108]

[114]

[120]

Change engine oil and engine oil filter.

X

X

X

X

Rotate tires.

X

X

X

X

Check spare tire for proper pressure and correct stowage.

X

X

X

X

Flush and replace engine coolant, if not done at 60 months.

X

Flush and replace engine coolant, if not done at 102,000
miles (170 000 km)

X

Inspect brake linings.

X

Replace engine air cleaner filter.

X

Replace make-up air filter.

X

Replace spark plugs.

X

Inspect PCV valve, replace as necessary.**

X

** This maintenance is recommended by the manufacturer to the owner, but not required to maintain the emissions
warranty.

Inspection and service should also be performed anytime a malfunction is observed or suspected. Retain all
receipts.

WARNING:
You can be badly injured working on or around a motor vehicle. Do only that service work for which you
have the knowledge and the right equipment. If you have any doubt about your ability to perform a service
job, take your vehicle to a competent mechanic.

MAINTENANCE SCHEDULES - GASOLINE ENGINES - EXPORT

There are two maintenance schedules that show the required service for your vehicle.

First is Schedule “A”. It lists all the scheduled maintenance to be performed under “normal” (if none of the condi-
tions in Schedule “B” apply to you) operating conditions.

Second is Schedule “B.” It is a schedule for vehicles that are operated under the conditions listed below.

Follow Schedule “B”if you usually operated you vehicle under one or more of the following conditions.

Day or night temperatures are below 0° C (32° F).

0 - 16

LUBRICATION & MAINTENANCE

PM

Stop and go driving.

Extensive engine idling.

Driving in dusty conditions.

Short trips of less than 16 km (10 miles).

More than 50% of your driving is at sustained high speeds during hot weather, above 32° C (90° F).

Trailer towing.

Taxi, police, or delivery service (commercial service).

Off-road or desert operation.

NOTE: If ANY of these apply to you then change your engine oil every 5 000 km (3,000 miles) or 3 months,
whichever comes first and follow schedule “B” of the

(

Maintenance Schedules

(

section of this manual.

NOTE: If ANY of these apply to you then change your coolant every 163 000 km (102,000 miles) or 60
months, whichever comes first and follow schedule “B” of the

(

Maintenance Schedules

(

section of this

manual.

NOTE: Most vehicles are operated under the conditions listed for Schedule

(

B

(

.

Use the schedule that best describes your driving conditions. Where time and mileage are listed, follow the interval
that occurs first.

CAUTION: Failure to perform the required maintenance items may result in damage to the vehicle.

At Each Stop for Fuel

Check the engine oil level about 5 minutes after a fully warmed engine is shut off. Checking the oil level while
the vehicle is on level ground will improve the accuracy of the oil level reading.

Check the windshield washer solvent and add if required.

Once a Month

Check tire pressure and look for unusual wear or damage.

Inspect the battery and clean and tighten the terminals as required.

Check the fluid levels of coolant reservoir, brake master cylinder, and transmission and add as needed.

Check all lights and all other electrical items for correct operation.

At Each Oil Change

Change the engine oil filter.

Inspect the exhaust system.

Inspect the brake hoses.

Inspect the CV joints (if equipped) and front suspension components.

Check the automatic transmission fluid level.

Check the coolant level, hoses, and clamps.

SCHEDULE A

Kilometers

12 000

24 000

36 000

48 000

60 000

(Miles)

(7,500)

(15,000)

(22,500)

(30,000)

(37,500)

[Months]

[6]

[12]

[18]

[24]

[30]

Change engine oil and engine oil filter.

X

X

X

X

X

Rotate tires.

X

X

X

X

X

Check spare tire for proper pressure and correct
stowage.

X

X

X

X

X

Inspect brake linings.

X

PM

LUBRICATION & MAINTENANCE

0 - 17

Kilometers

12 000

24 000

36 000

48 000

60 000

(Miles)

(7,500)

(15,000)

(22,500)

(30,000)

(37,500)

[Months]

[6]

[12]

[18]

[24]

[30]

Replace engine air cleaner filter.

X

Replace make-up air filter.

X

Replace spark plugs.

X

Kilometers

72 000

84 000

96 000

108
000

120
000

132 000

(Miles)

(45,000)

(52,500)

(60,000)

(67,500)

(75,000)

(82,500)

[Months]

[36]

[42]

[48]

[54]

[60]

[66]

Change engine oil and engine oil filter.

X

X

X

X

X

X

Rotate tires.

X

X

X

X

X

X

Check spare tire for proper pressure and correct
stowage.

X

X

X

X

X

X

Flush and replace engine coolant at 60 months,
regardless of mileage.

X

Inspect brake linings.

X

X

Replace engine air cleaner filter.

X

Replace make-up air filter.

X

Replace spark plugs.

X

Inspect PCV valve, replace as necessary.

X

Inspect auto tension drive belt and replace if
required.

X

Kilometers

144
000

156 000

160
000

168
000

181
000

192 000

(Miles)

(90,000)

(97,500) (100,000) (105,000) (112,500) (120,000)

[Months]

[72]

[78]

[84]

[90]

[96]

Change engine oil and engine oil filter.

X

X

X

X

X

Rotate tires.

X

X

X

X

X

X

Check spare tire for proper pressure and correct
stowage.

X

X

X

X

X

Flush and replace engine coolant, if not done at
60 mos.

X

Inspect brake linings.

X

X

Replace engine air cleaner filter.

X

X

Replace make-up air filter.

X

X

Replace spark plugs.

X

X

Inspect PCV valve, replace as necessary.

X

X

Inspect auto tension drive belt and replace if
required.

X

Inspection and service should also be performed anytime a malfunction is observed or suspected. Retain all
receipts.

0 - 18

LUBRICATION & MAINTENANCE

PM

 

 

 

 

 

 

 

Content   ..  4  5  6  7   ..