Kia Carens. Manual - part 319

  2001 > 1.8L DOHC >

 

REMOVAL

1. Discharge refrigeration system. (Refer to operating instructions of your refrigerant recovery/recycling

/charging station for proper procedures.)

2. Remove receiver/drier a shown in figure.

Immediately plug open fittings to keep moisture out of system

INSTALLATION

Install receiver/drier in reverse order of removal.

1) Apply clean compressor oil to O-rings before connecting fittings.
2) Do not apply compressor oil to fitting nuts.
3) When installing a new receiver/drier, add compressor oil through high-pressure pipe port of

compressor.
Compressor oil: 0.61 cu in (10 cc)

Tightening torque
Receiver/drier inlet: 43~61 lb-in (4.9~6.9 N0m, 50~70 kg-cm)
Receiver/drier outlet: 43~61 lb-in (4.9~6.9 N-m, 50~70 kg-cm)

Heating,Ventilation, Air Conditioning

Air Conditioning System - A/C Control Relay

Heating,Ventilation, Air Conditioning

  2001 > 1.8L DOHC >

 

INSPECTION

A/C relay

1. Disconnect A/C relay connector.

2. Check continuity between terminals.

Terminals

Continuity

Tester probe: +

Tester probe: -

85

86

Yes

85

87

No

85

30

No

87

86

No

87

30

No

3. If not as specified, replace relay.

4. If correct, go to next step.

5. Apply 12V to terminal 85 and ground terminal 86.

6. Check for continuity between terminals 87 and 30.

Terminals

Continuity

87-30

Yes

7. If not as specified, replace relay.

Heating,Ventilation, Air Conditioning

Air Conditioning System - Refrigerant Line

Heating,Ventilation, Air Conditioning