Model MA TOW Tractor. Manual - part 22

Chapter 3: Overhaul

Dec. 1995                     Section 3-6                       p. 13

(b)

Bleed both rear calipers, then, bleed both front calipers. This provides the most

effective means for expelling all air from the brake system when pressure bleeding.

NOTE: The pressure bleeding process may be speeded up by lightly tapping the

brake pedal vhen the bleeder valve is opened. This creates pulsations that tend to
purge air from the system.

4.

Check-Out:

(a)

Check brake pedal for sponginess or hard pedal.

(b)

Drive tractor slowly and make several slow speed stops.

(c)

Check all brake fluid line fittings and caliper areas for fluid leakage.

(d)

Correct any discrepancies before returning tractor to normal service.

Chapter 3: Overhaul

Dec. 1995                     Section 3-6                        p. 14

(This Page Intentionally Left Blank)

Chapter 4: Illustrated Parts List

Jan.  1997

Section  4-Contents

  p. 1

CHAPTER 4

Table of Contents

Illustrated Parts List

Section:

    Page

I.

DESCRIPTION ........................................................................................................................................ 1

A.

INTRODUCTION ........................................................................................................................... 1

B.

USING THE ILLUSTRATED PARTS LIST (IPL) ............................................................................ 1

C.

ORDERING SPARE PARTS .......................................................................................................... 4

D.

VENDOR CODES REFERENCE LIST .......................................................................................... 4

II.

ILLUSTRATED PARTS LIST ................................................................................................................. 1

FIGURE 1: FRAME ASSEMBLY ............................................................................................................. 2

FIGURE 1: FRAME ASSEMBLY ............................................................................................................. 4

FIGURE 1: FRAME ASSEMBLY ............................................................................................................. 6

FIGURE 2: ENGINE COMPARTMENT ASSEMBLY ............................................................................... 8

FIGURE 2: ENGINE COMPARTMENT ASSEMBLY ............................................................................. 10

FIGURE 3: SEAT ASSEMBLY ............................................................................................................... 12

FIGURE 3: SEAT ASSEMBLY ............................................................................................................... 14

FIGURE 4: FIREWALL, OPERATOR'S SIDE ....................................................................................... 16

FIGURE 4: FIREWALL, OPERATOR'S SIDE ....................................................................................... 18

FIGURE 4: FIREWALL, OPERATOR'S SIDE ....................................................................................... 20

FIGURE 5: FIREWALL, ENGINE SIDE ................................................................................................. 22

FIGURE 5: FIREWALL, ENGINE SIDE ................................................................................................. 24

FIGURE 6: INSTRUMENT PANEL ASSEMBLY ................................................................................... 26

FIGURE 6: INSTRUMENT PANEL ASSEMBLY ................................................................................... 28

FIGURE 7: MORSE SHIFTER ASSEMBLY .......................................................................................... 30

FIGURE 7: MORSE SHIFTER ASSEMBLY .......................................................................................... 32

Chapter 4: Illustrated Parts List

Jan.  1997

Section  4-Contents

  p. 2

Illustrated Parts List

Section:

    Page

FIGURE 8: QUADRASTAT SHIFTER ASSEMBLY ............................................................................... 34

FIGURE 9: TRANSMISSION SHIFTER LINKAGE ASSEMBLY ........................................................... 36

FIGURE 10: ACCELERATOR CABLE AND LINKAGE ASSEMBLY ..................................................... 38

FIGURE 10: ACCELERATOR CABLE AND LINKAGE ASSEMBLY ..................................................... 40

FIGURE 11:BRAKE PEDAL, BOOSTER AND MASTER CYLINDER ASSEMBLY ............................... 42

FIGURE 12: HEADLIGHT ASSEMBLY ................................................................................................. 44

FIGURE 13: TAIL LIGHT/STOP LIGHT AND BACK UP LIGHT ASSEMBLY ....................................... 46

FIGURE 14: FRONT TURN SIGNAL ASSEMBLY ................................................................................ 48

FIGURE 15: BATTERY AND BATTERY BOX INSTALLATION ............................................................. 50

FIGURE 16: SPEEDOMETER INSTALLATION .................................................................................... 52

FIGURE 17: ENGINE AND ENGINE MOUNTS INSTALLATION - FORD GASOLINE ENGINE .......... 54

FIGURE 17: ENGINE AND ENGINE MOUNTS INSTALLATION - FORD GASOLINE ENGINE .......... 56

FIGURE 18: ENGINE AND ENGINE MOUNTS INSTALLATION - CUMMINS/ONAN ENGINE ........... 58

FIGURE 18A: ENGINE AND ENGINE MOUNTS INSTALLATION - HERCULES DIESEL ENGINE .... 60

FIGURE 18B: PERKINS 1004 DIESEL ENGINE INSTALLATION ........................................................ 62

FIGURE 19: C6 TRANSMISSION AND TRANSMISSION MOUNTS INSTALLATION,

GASOLINE AND CUMMINS/ONAN DIESEL ENGINE ......................................................................... 64

FIGURE 19: TRANSMISSION AND TRANSMISSION MOUNTS INSTALLATION,

GASOLINE AND CUMMINS/ONAN DIESEL ENGINE ......................................................................... 66

FIGURE 20: TRANSMISSION AND TRANSMISSION  MOUNTS INSTALLATION,

PERKINS 4.236 DIESEL ENGINE ........................................................................................................ 68

FIGURE 20: TRANSMISSION AND TRANSMISSION  MOUNTS INSTALLATION,

PERKINS 4.236 DIESEL ENGINE ........................................................................................................ 70

FIGURE 21: AIR CLEANER ASSEMBLY, GASOLINE ENGINE ........................................................... 72

FIGURE 22: AIR CLEANER ASSEMBLY, DIESEL ENGINE (WITHOUT PRE-FILTER) ...................... 74

FIGURE 23: AIR CLEANER ASSEMBLY, DIESEL ENGINE (WITH PRE-FILTER) .............................. 76

FIGURE 24: EXHAUST SYSTEM INSTALLATION ............................................................................... 78