|
|
|
The following abbreviations are used to represent values for Control Module Pin-Out data
I
Input
D
Serial and Encoded Data
B+
Battery Voltage
kHz
Frequency x 1000
O
Output
C
CAN (Network)
V
Voltage (DC)
ms
Milliseconds
SG
Signal Ground
S
SCP Network
Hz
Frequency
mV
Millivolts
CAUTION: The information on this data page is furnished to aid the user in understanding circuit operation.
THIS INFORMATION SHOULD BE USED FOR
REFERENCE ONLY.
NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all
components connected and fitted.
“Active” means a load is applied or a switch is ON; “Inactive” means a load is not applied or a switch is OFF.
Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, grounds, control
modules and control module pins.
DATE OF ISSUE:
October 1999
Fig. 09.1
COMPONENTS
Component
Connector / Type / Color
Location / Access
BODY PROCESSOR MODULE
FC15 / 14-WAY AMP EEEC / GREY
BULKHEAD / BEHIND GLOVE BOX
CENTER CONSOLE SWITCH PACK
CC1 / 16-WAY FORD IDC S.U. / BLACK
CENTER CONSOLE SWITCH PACK
DIRECTION INDICATOR LAMP – LH FRONT
BL2 / 2-WAY REINSHAGEN / VOLKSWAGEN / BLACK
FRONT BUMPER – LH SIDE
DIRECTION INDICATOR LAMP – RH FRONT
BR2 / 2-WAY REINSHAGEN / VOLKSWAGEN / BLACK
FRONT BUMPER – RH SIDE
FOG LAMP SWITCHES
FC3 / 10-WAY AMP MICRO QUAD LOCK / NATURAL
FASCIA / OUTBOARD OF STEERING COLUMN
FOG LAMP – LH FRONT
BL4 / 2-WAY DELPHI / PACKARD METRIPACK 280 / GREY
FRONT BUMPER – LH SIDE
FOG LAMP – RH FRONT
BR4 / 2-WAY DELPHI / PACKARD METRIPACK 280 / GREY
FRONT BUMPER – RH SIDE
LAMP UNIT – LH FRONT
LF38 / 6-WAY AUGAT 1.6 / BLACK
ENGINE COMPARTMENT / LH FRONT
LAMP UNIT – RH FRONT
LF40 / 6-WAY AUGAT 1.6 / BLACK
ENGINE COMPARTMENT / RH FRONT
FUSE BOX – ENGINE COMPARTMENT
LF5 / 10-WAY U.T.A. FUSE BOX / NATURAL
ENGINE COMPARTMENT / LH FRONT
LF6 / 10-WAY U.T.A. FUSE BOX / BLACK
LF7 / 10-WAY U.T.A. FUSE BOX / GREEN
LF8 / 10-WAY U.T.A. FUSE BOX / BLUE
ST19 / EYELET
INSTRUMENT PACK
FC24 / 26-WAY AMP MICRO QUAD LOCK / BLACK
FASCIA
FC25 / 26-WAY AMP MICRO QUAD LOCK / YELLOW
LIGHTING STALK (COLUMN SWITCHGEAR)
SC2 / 10-WAY MULTILOCK 070 / YELLOW
COLUMN SWITCHGEAR HARNESS /
ADJACENT TO STEERING COLUMN MOTOR
SIDE DI REPEATER – LH (ROW ONLY)
LF17 / 2-WAY AMP JUNIOR POWER TIMER / BLACK
BEHIND LEFT HAND WHEEL ARCH LINER
SIDE DI REPEATER – RH (ROW ONLY)
CA80 / 2-WAY AMP JUNIOR POWER TIMER / BLACK
BEHIND RIGHT HAND WHEEL ARCH LINER
SIDE MARKER – LH FRONT (NAS ONLY)
BL5 / 2-WAY REINSHAGEN / VOLKSWAGEN / BLACK
FRONT BUMPER – LH SIDE
SIDE MARKER – RH FRONT (NAS ONLY)
BR5 / 2-WAY REINSHAGEN / VOLKSWAGEN / BLACK
FRONT BUMPER – RH SIDE
RELAYS
Relay
Case Color
Connector / Color
Location / Access
DIP BEAM RELAY
BROWN
BUS
RELAY #5, ENGINE COMPARTMENT FUSE BOX / ENGINE COMPARTMENT
FRONT FOG RELAY
BROWN
BUS
RELAY #2, ENGINE COMPARTMENT FUSE BOX / ENGINE COMPARTMENT
MAIN BEAM RELAY
BROWN
BUS
RELAY #3, ENGINE COMPARTMENT FUSE BOX / ENGINE COMPARTMENT
HARNESS-TO-HARNESS CONNECTORS
Connector
Type / Color
Location / Access
BL1
4-WAY AUGAT 1.6 / BLACK
BEHIND LEFT HAND WHEEL ARCH LINER
BR1
4-WAY AUGAT 1.6 / BLACK
ADJACENT TO BOTTOM OF WASHER FLUID RESERVOIR
FC5
54-WAY THROUGH PANEL CONNECTOR / GREY
BELOW DRIVER SIDE AIR VENT / COIN TRAY
FC7
20-WAY MULTILOCK 070 / YELLOW
ABOVE DIMMER MODULE / COIN TRAY
LF3
54-WAY THROUGH PANEL CONNECTOR / GREY
LH ‘A’ POST / LOWER ‘A’ POST FINISHER
GROUNDS
Ground
Location / Type
CC3L
EYELET (PAIR) – RH FRONT BULKHEAD STUD / CABIN SIDE
CC3R
EYELET (PAIR) – RH FRONT BULKHEAD STUD / CABIN SIDE
FC17L
EYELET (PAIR) – EMS BULKHEAD GROUND STUD
FC17R
EYELET (PAIR) – EMS BULKHEAD GROUND STUD
LF18L
EYELET (PAIR) – LH FORWARD GROUND STUD
LF19R
EYELET (PAIR) – RH FORWARD GROUND STUD
FOR CONTROL MODULE PIN OUT INFORMATION, UNFOLD PAGE TO LEFT.
CONTROL MODULE PIN OUT INFORMATION
BODY PROCESSOR MODULE
P
Pin
Description
Active
Inactive
O
FC15-1
RH FRONT SIDE LAMP SUPPLY
B+
GROUND
O
FC15-2
LH FRONT DI LAMP SUPPLY
B+ (PULSED)
GROUND
O
FC15-3
RH FRONT DI LAMP SUPPLY
B+ (PULSED)
GROUND
I
FC15-14
HEADLAMP MAIN BEAM REQUEST
GROUND
B+
I
FC15-15
IGNITION SWITCHED GROUND
GROUND
B+
I
FC15-16
SIDE LAMP REQUEST
GROUND
B+
O
FC15-20
FRONT FOG LAMP RELAY ACTIVATE
GROUND
B+
O
FC15-27
LH SIDE DI REPEATER LAMP SUPPLY (ROW ONLY)
B+ (PULSED)
GROUND
I
FC15-30
HEADLAMP FLASH REQUEST
GROUND (MOMENTARY)
B+
I
FC15-38
FRONT FOG LAMP REQUEST
GROUND
B+
I
FC15-41
STARTER ENGAGE REQUEST
GROUND (CRANKING)
B+
I
FC15-42
HEADLAMP DIP REQUEST
GROUND (MOMENTARY)
B+
O
FC15-45
MAIN BEAM RELAY ACTIVATE
GROUND
B+
O
FC15-53
LH FRONT SIDE LAMP SUPPLY
B+
GROUND
I
FC15-59
HAZARD LAMP REQUEST
GROUND (MOMENTARY)
B+
I
FC15-61
RH DI REQUEST
GROUND
B+
O
FC15-68
DIP BEAM RELAY ACTIVATE
GROUND
B+
I
FC15-79
BATTERY SUPPLY VOLTAGE
B+
B+
I
FC15-80
BATTERY SUPPLY VOLTAGE
B+
B+
O
FC15-81
RH SIDE DI REPEATER LAMP SUPPLY (ROW ONLY)
B+ (PULSED)
GROUND
S
FC15-84
SCP NETWORK
2 – 1600 Hz
S
FC15-85
SCP NETWORK
2 – 1600 Hz
I
FC15-88
LH DI REQUEST
GROUND
B+
O
FC15-96
HAZARD LAMP STATUS
GROUND (PULSE)
B+
INSTRUMENT PACK
P
Pin
Description
Active
Inactive
S
FC24-13
SCP NETWORK
2 – 1600 Hz
S
FC24-14
SCP NETWORK
2 – 1600 Hz
NOTE: Refer to the Appendix at the rear of this book for CAN and SCP Network messages.
The following abbreviations are used to represent values for Control Module Pin-Out data
I
Input
D
Serial and Encoded Data
B+
Battery Voltage
kHz
Frequency x 1000
O
Output
C
CAN (Network)
V
Voltage (DC)
ms
Milliseconds
SG
Signal Ground
S
SCP Network
Hz
Frequency
mV
Millivolts
CAUTION: The information on this data page is furnished to aid the user in understanding circuit operation.
THIS INFORMATION SHOULD BE USED FOR
REFERENCE ONLY.
NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all
components connected and fitted.
“Active” means a load is applied or a switch is ON; “Inactive” means a load is not applied or a switch is OFF.
Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, grounds, control
modules and control module pins.
DATE OF ISSUE:
October 1999
Fig. 09.2
COMPONENTS
Component
Connector / Type / Color
Location / Access
BODY PROCESSOR MODULE
FC15 / 14-WAY AMP EEEC / GREY
BULKHEAD / BEHIND GLOVE BOX
BRAKE SWITCH
CC40 / 4-WAY MULTILOCK 070 / WHITE
ADJACENT TO THE BRAKE PEDAL MOUNTING ASSEMBLY
CENTER CONSOLE SWITCH PACK
CC1 / 16-WAY FORD IDC S.U. / BLACK
CENTER CONSOLE SWITCH PACK
DIODE (BT40) – NUMBER PLATE
BT40 / 2-WAY DIODE MODULE ASSEMBLY
ADJACENT TO BATTERY / BATTERY COVER
FOG LAMP SWITCHES
FC3 / 10-WAY AMP MICRO QUAD LOCK / NATURAL
FASCIA / OUTBOARD OF STEERING COLUMN
FUSE BOX – TRUNK
BT10 / 10-WAY U.T.A. FUSE BOX / NATURAL
TRUNK ELECTRICAL CARRIER
BT11 / 10-WAY U.T.A. FUSE BOX / BLACK
BT12 / 10-WAY U.T.A. FUSE BOX / GREEN
BT13 / 10-WAY U.T.A. FUSE BOX / BLUE
BT64 / EYELET
HIGH MOUNTED STOP LAMP
CA35 / 2-WAY YAZAKI / NATURAL
BACKLIGHT
INSTRUMENT PACK
FC24 / 26-WAY AMP MICRO QUAD LOCK / BLACK
FASCIA
FC25 / 26-WAY AMP MICRO QUAD LOCK / YELLOW
LIGHTING STALK (COLUMN SWITCHGEAR)
SC2 / 10-WAY MULTILOCK 070 / YELLOW
COLUMN SWITCHGEAR HARNESS /
ADJACENT TO STEERING COLUMN MOTOR
NUMBER PLATE LAMP – LH
BT27 / 2-WAY AMP POSILOCK II / BLACK
BEHIND TRUNK LID LINER
NUMBER PLATE LAMP – RH
BT26 / 2-WAY AMP POSILOCK II / BLACK
BEHIND TRUNK LID LINER
REAR SIDE MARKER – LH (NAS ONLY)
BT29 / 2-WAY REINSHAGEN / VOLKSWAGEN / BLACK
TRUNK LH SIDE / TRUNK CARPET
REAR SIDE MARKER – RH (NAS ONLY)
BT31 / 2-WAY REINSHAGEN / VOLKSWAGEN / BLACK
TRUNK RH SIDE / TRUNK CARPET
SECURITY AND LOCKING CONTROL MODULE
BT1 / 16-WAY FORD 2.8 TIMER / BLACK
BELOW TRUNK FUSE BOX
BT2 / 26-WAY FORD IDC / BLACK
BT6 / 2-WAY COAXIAL CONNECTOR / BLACK
TAIL LAMP UNIT – LH
BT51 / 7-WAY FRAM – FORD 2.8 TIMER / BLACK
TRUNK LH SIDE / REAR LAMP COVER
TAIL LAMP UNIT – RH
BT50 / 7-WAY FRAM – FORD 2.8 TIMER / BLACK
TRUNK RH SIDE / REAR LAMP COVER
TRAILER CONNECTOR
BT32 / 14-WAY MULTILOCK 070 / YELLOW
ABOVE TRUNK FUSE BOX
RELAYS
Relay
Case Color
Connector / Color
Location / Access
STOP LAMP RELAY
BROWN
BUS
RELAY #5, TRUNK FUSE BOX / TRUNK
SIDE MARKER AND NUMBER PLATE LAMP RELAY
BROWN
BUS
RELAY #3, TRUNK FUSE BOX / TRUNK
HARNESS-TO-HARNESS CONNECTORS
Connector
Type / Color
Location / Access
BT4
54-WAY THROUGH PANEL / GREY
BELOW PARCEL SHELF / TRUNK / REAR BULKHEAD / RH SIDE
CA19
20-WAY MULTILOCK 070 / YELLOW
LH ‘A’ POST CONNECTOR MOUNTING BRACKET / LOWER ‘A’ POST FINISHER
FC1
54-WAY THROUGH PANEL CONNECTOR / GREY
BELOW PASSENGER SIDE AIR VENT / GLOVE BOX ASSEMBLY
FC5
54-WAY THROUGH PANEL CONNECTOR / GREY
BELOW DRIVER SIDE AIR VENT / COIN TRAY
FC7
20-WAY MULTILOCK 070 / YELLOW
ABOVE DIMMER MODULE / COIN TRAY
GROUNDS
Ground
Location / Type
BT20
EYELET (SINGLE) – TRUNK / RH REAR GROUND STUD
BT21L
EYELET (PAIR) – TRUNK / RH REAR GROUND STUD
BT22L*
EYELET (PAIR) – TRUNK / RH CENTER GROUND STUD (*PREMIUM ICE)
BT24*
EYELET (SINGLE) – TRUNK / RH CENTER GROUND STUD (*STANDARD ICE)
CA31L
EYELET (PAIR) – RH DRIVE SHAFT TUNNEL GROUND STUD
CC3L
EYELET (PAIR) – RH FRONT BULKHEAD STUD / CABIN SIDE
CC3R
EYELET (PAIR) – RH FRONT BULKHEAD STUD / CABIN SIDE
FC17L
EYELET (PAIR) – EMS BULKHEAD GROUND STUD
FC17R
EYELET (PAIR) – EMS BULKHEAD GROUND STUD
FOR CONTROL MODULE PIN OUT INFORMATION, UNFOLD PAGE TO LEFT.
CONTROL MODULE PIN OUT INFORMATION
BODY PROCESSOR MODULE
P
Pin
Description
Active
Inactive
I
FC15-12
REAR FOG LAMP REQUEST
GROUND
B+
I
FC15-15
IGNITION SWITCHED GROUND
GROUND
B+
I
FC15-16
SIDE LAMP REQUEST
GROUND
B+
O
FC15-28
RH TAIL LAMP SUPPLY
B+
GROUND
I
FC15-41
STARTER ENGAGE REQUEST
GROUND (CRANKING)
B+
O
FC15-44
REAR FOG LAMP STATUS
GROUND
B+
O
FC15-49
TRAILER RH DI LAMP SUPPLY
B+ (PULSED)
GROUND
O
FC15-50
LH DI LAMP SUPPLY
B+ (PULSED)
GROUND
O
FC15-54
LH TAIL LAMP SUPPLY
B+
GROUND
I
FC15-59
HAZARD LAMP REQUEST
GROUND (MOMENTARY)
B+
I
FC15-61
RH DI REQUEST
GROUND
B+
O
FC15-75
TRAILER LH DI LAMP SUPPLY
B+ (PULSED)
GROUND
O
FC15-76
RH DI LAMP SUPPLY
B+ (PULSED)
GROUND
I
FC15-79
BATTERY SUPPLY VOLTAGE
B+
B+
I
FC15-80
BATTERY SUPPLY VOLTAGE
B+
B+
S
FC15-84
SCP NETWORK
2 – 1600 Hz
S
FC15-85
SCP NETWORK
2 – 1600 Hz
I
FC15-88
LH DI REQUEST
GROUND
B+
O
FC15-95
SIDE MARKER & NUMBER PLATE LAMP RELAY ACTIVATE
GROUND
B+
O
FC15-96
HAZARD LAMP STATUS
GROUND (PULSE)
B+
I
FC15-104
BATTERY SUPPLY VOLTAGE
B+
B+
INSTRUMENT PACK
P
Pin
Description
Active
Inactive
C
FC24-11
CAN NETWORK
15 – 1500 Hz
S
FC24-13
SCP NETWORK
2 – 1600 Hz
S
FC24-14
SCP NETWORK
2 – 1600 Hz
C
FC24-24
CAN NETWORK
15 – 1500 Hz
SECURITY AND LOCKING CONTROL MODULE
P
Pin
Description
Active
Inactive
O
BT1-3
RH STOP LAMP SUPPLY
B+
GROUND
O
BT1-4
REAR FOG LAMP SUPPLY
B+
GROUND
O
BT1-5
REVERSE LAMP SUPPLY
B+
GROUND
I
BT1-6
BATTERY SUPPLY
B+
B+
O
BT1-7
SPLIT CHARGE CONTROL
S
BT1-8
SCP NETWORK
2 – 1600 Hz
O
BT1-9
LH STOP LAMP SUPPLY
B+
GROUND
I
BT1-13
LOGIC GROUND
GROUND
GROUND
I
BT1-14
LOGIC GROUND
GROUND
GROUND
S
BT1-16
SCP NETWORK
2 – 1600 Hz
I
BT2-1
BRAKE SWITCH STATUS
GROUND (BRAKE ON)
B+
I
BT2-6
TRAILER CONNECTION STATUS
GROUND (TRAILER PRESENT)
B+ (NO TRAILER)
NOTE: Refer to the Appendix at the rear of this book for CAN and SCP Network messages.
Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, grounds, control
modules and control module pins.
DATE OF ISSUE:
October 1999
Fig. 09.3
COMPONENTS
Component
Connector / Type / Color
Location / Access
HEADLAMP LEVELING ACTUATOR – LH
LF41 / 3-WAY REINSHAGEN / BLACK
ENGINE COMPARTMENT / LH HEADLAMP
HEADLAMP LEVELING ACTUATOR – RH
LF42 / 3-WAY REINSHAGEN / BLACK
ENGINE COMPARTMENT / RH HEADLAMP
HEADLAMP LEVELING SWITCH
FC14 / 6-WAY JAE IL-AG5 / GREEN
FASCIA SWITCH PACK
(FASCIA SWITCH PACK)
HARNESS-TO-HARNESS CONNECTORS
Connector
Type / Color
Location / Access
FC5
54-WAY THROUGH PANEL CONNECTOR / GREY
BELOW DRIVER SIDE AIR VENT / COIN TRAY
LF3
54-WAY THROUGH PANEL CONNECTOR / GREY
LH ‘A’ POST / LOWER ‘A’ POST FINISHER
GROUNDS
Ground
Location / Type
FC17L
EYELET (PAIR) – EMS BULKHEAD GROUND STUD
LF18L
EYELET (PAIR) – LH FORWARD GROUND STUD
LF19R
EYELET (PAIR) – RH FORWARD GROUND STUD
The following abbreviations are used to represent values for Control Module Pin-Out data
I
Input
D
Serial and Encoded Data
B+
Battery Voltage
kHz
Frequency x 1000
O
Output
C
CAN (Network)
V
Voltage (DC)
ms
Milliseconds
SG
Signal Ground
S
SCP Network
Hz
Frequency
mV
Millivolts
CAUTION: The information on this data page is furnished to aid the user in understanding circuit operation.
THIS INFORMATION SHOULD BE USED FOR
REFERENCE ONLY.
NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all
components connected and fitted.
“Active” means a load is applied or a switch is ON; “Inactive” means a load is not applied or a switch is OFF.
Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, grounds, control
modules and control module pins.
DATE OF ISSUE:
October 1999
Fig. 10.1
COMPONENTS
Component
Connector / Type / Color
Location / Access
BODY PROCESSOR MODULE
FC15 / 14-WAY AMP EEEC / GREY
BULKHEAD / BEHIND GLOVE BOX
DOOR CONTROL MODULE – DRIVER
DD10 / 22-WAY FORD 2.8 TIMER / BLUE
DOOR CASING / TRIM PANEL
DD11 / 22-WAY FORD 2.8 TIMER / BLACK
DOOR CONTROL MODULE – DRIVER REAR
RD10 / 22-WAY FORD 2.8 TIMER / BLUE
DOOR CASING / TRIM PANEL
RD11 / 22-WAY FORD 2.8 TIMER / BLACK
DOOR CONTROL MODULE – PASSENGER
PD10 / 22-WAY FORD 2.8 TIMER / BLUE
DOOR CASING / TRIM PANEL
PD11 / 22-WAY FORD 2.8 TIMER / BLACK
DOOR CONTROL MODULE – PASSENGER REAR
RP10 / 22-WAY FORD 2.8 TIMER / BLUE
DOOR CASING / TRIM PANEL
RP11 / 22-WAY FORD 2.8 TIMER / BLACK
DOOR LOCK SWITCHES – DRIVER
DD3 / 13-WAY ECONOSEAL III LC / BLACK
DOOR CASING / TRIM PANEL
DOOR SWITCH – DRIVER
DD3 / 13-WAY ECONOSEAL III LC / BLACK
DOOR CASING / TRIM PANEL
DOOR SWITCH – DRIVER REAR
RD3 / 6-WAY ECONOSEAL III LC / BLACK
DOOR CASING / TRIM PANEL
DOOR SWITCH – PASSENGER
PD3 / 13-WAY ECONOSEAL III LC / BLACK
DOOR CASING / TRIM PANEL
DOOR SWITCH – PASSENGER REAR
RP3 / 6-WAY ECONOSEAL III LC / BLACK
DOOR CASING / TRIM PANEL
‘E’ POST LAMP – LH
IC4 / 4-WAY MULTILOCK 040 / BLACK
LH ‘E’ POST / ‘E’ POST TRIM
‘E’ POST LAMP – RH
CA5 / 4-WAY MULTILOCK 040 / BLACK
RH ‘E’ POST / ‘E’ POST TRIM
GARAGE DOOR OPENER
CA53 / 8-WAY MULTILOCK 040 / BLACK
ROOF CONSOLE
GLOVE BOX LAMP
FC33 / 1-WAY LUCAR 02 / CLEAR
GLOVE BOX
FC34 / 1-WAY LUCAR 02 / CLEAR
IGNITION SWITCH (KEY-IN SWITCH)
FC4 / 8-WAY MULTILOCK 070 / WHITE
STEERING COLUMN
PUDDLE LAMP – DRIVER REAR DOOR
RD14 / 2-WAY AMP JUNIOR TIMER / BLACK
DOOR CASING / TRIM PANEL
PUDDLE LAMP – DRIVER DOOR
DD14 / 2-WAY AMP JUNIOR TIMER / BLACK
DOOR CASING / TRIM PANEL
PUDDLE LAMP – DRIVER PASSENGER
PD14 / 2-WAY AMP JUNIOR TIMER / BLACK
DOOR CASING / TRIM PANEL
PUDDLE LAMP – PASSENGER REAR DOOR
RP14 / 2-WAY AMP JUNIOR TIMER / BLACK
DOOR CASING / TRIM PANEL
TRUNK LAMP – LH
|
|
|