|
|
|
Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, grounds, control
modules and control module pins.
DATE OF ISSUE:
October 1999
Fig. 01.5
COMPONENTS
Component
Connector / Type / Color
Location / Access
FUSE BOX – ENGINE MANAGEMENT
EM19 / 10-WAY U.T.A. FUSE BOX / NATURAL
ENGINE COMPARTMENT / CONTROL MODULE ENCLOSURE
EM20 / 10-WAY U.T.A. FUSE BOX / BLACK
ST20 / EYELET
ST21 / EYELET
HARNESS-TO-HARNESS CONNECTORS
Connector
Type / Color
Location / Access
CV2
3-WAY MULTILOCK 070 / WHITE
UNDER REAR SEAT
EM2
20-WAY MULTILOCK 070 / GREY
PASSENGER ‘A’ POST / LOWER ‘A’ POST FINISHER
EM51
12-WAY AUGAT 1.6 / GREY
ENGINE COMPARTMENT / ADJACENT TO ABS PUMP
FC1
54-WAY THROUGH PANEL CONNECTOR / GREY
BELOW PASSENGER SIDE AIR VENT / GLOVE BOX ASSEMBLY
PI1
57-WAY SUMITOMO TS090 / BLACK
ENGINE COMPARTMENT / BULKHEAD / REAR OF ENGINE
Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, grounds, control
modules and control module pins.
DATE OF ISSUE:
October 1999
Fig. 02.1
COMPONENTS
Component
Connector / Type / Color
Location / Access
IGNITION SWITCH
FC4 / 8-WAY MULTILOCK 070 / WHITE
STEERING COLUMN
INERTIA SWITCH
CA6 / 3-WAY ECONOSEAL III LC / BLACK
RH ‘A’ POST / LOWER ‘A’ POST FINISHER
HARNESS-TO-HARNESS CONNECTORS
Connector
Type / Color
Location / Access
BT4
54-WAY THROUGH PANEL / GREY
BELOW PARCEL SHELF / TRUNK / REAR BULKHEAD / RH SIDE
CA19
20-WAY MULTILOCK 070 / YELLOW
LH ‘A’ POST CONNECTOR MOUNTING BRACKET / LOWER ‘A’ POST FINISHER
CA20
20-WAY MULTILOCK 070 / YELLOW
RH ‘A’ POST CONNECTOR MOUNTING BRACKET / LOWER ‘A’ POST FINISHER
EM53
20-WAY MULTILOCK 070 / WHITE
RH ‘A’ POST / LOWER ‘A’ POST FINISHER
FC1
54-WAY THROUGH PANEL CONNECTOR / GREY
BELOW PASSENGER SIDE AIR VENT / GLOVE BOX ASSEMBLY
FC11
18-WAY MULTILOCK 070 / WHITE
ABOVE DIMMER MODULE / COIN TRAY
LF3
54-WAY THROUGH PANEL CONNECTOR / GREY
LH ‘A’ POST / LOWER ‘A’ POST FINISHER
GROUNDS
Ground
Location / Type
FC17L
EYELET (PAIR) – EMS BULKHEAD GROUND STUD
The following abbreviations are used to represent values for Control Module Pin-Out data
I
Input
D
Serial and Encoded Data
B+
Battery Voltage
kHz
Frequency x 1000
O
Output
C
CAN (Network)
V
Voltage (DC)
ms
Milliseconds
SG
Signal Ground
S
SCP Network
Hz
Frequency
mV
Millivolts
CAUTION: The information on this data page is furnished to aid the user in understanding circuit operation.
THIS INFORMATION SHOULD BE USED FOR
REFERENCE ONLY.
NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all
components connected and fitted.
“Active” means a load is applied or a switch is ON; “Inactive” means a load is not applied or a switch is OFF.
Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, grounds, control
modules and control module pins.
DATE OF ISSUE:
October 1999
Fig. 03.1
COMPONENTS
Component
Connector / Type / Color
Location / Access
BATTERY
BT66 / BATTERY CABLE CLAMP
TRUNK / BATTERY COVER
BT67 / BATTERY CABLE CLAMP
BODY PROCESSOR MODULE
FC15 / 14-WAY AMP EEEC / GREY
BULKHEAD / BEHIND GLOVE BOX
ENGINE CONTROL MODULE
EM80 / 31-WAY AMP 403 / NATURAL
ENGINE COMPARTMENT / CONTROL MODULE ENCLOSURE
EM81 / 24-WAY AMP 403 / NATURAL
EM82 / 17-WAY AMP 403 / NATURAL
EM83 / 28-WAY AMP 403 / NATURAL
EM84 / 22-WAY AMP 403 / NATURAL
EM85 / 12-WAY MULTILOCK 070 / WHITE
GENERATOR
AN1 / EYELET
ENGINE COMPARTMENT / RH FRONT
AN2 / EYELET
ST4 / EYELET
HIGH POWER PROTECTION MODULE
BT60 / EYELET
TRUNK / ADJACENT TO BATTERY
BT61 / EYELET
BT62 / EYELET
BT63 / EYELET
IGNITION SWITCH
FC4 / 8-WAY MULTILOCK 070 / WHITE
STEERING COLUMN
KEY TRANSPONDER MODULE
FC22 / 20-WAY MULTILOCK 040 / GREEN
BELOW INSTRUMENT PACK
NEUTRAL SWITCH
CC21 / 3-WAY MULTILOCK 070 / GREY
GEAR SELECTOR ASSEMBLY / CENTER CONSOLE
REGULATOR (GENERATOR)
PI50 / 3-WAY SUMITOMO 92 / BLACK
ENGINE COMPARTMENT / RH FRONT
STARTER MOTOR
ST1 / EYELET
ENGINE COMPARTMENT / ENGINE BLOCK / RH SIDE
ST2 / EYELET
ST3 / EYELET
SUPPRESSION MODULE
AN3 / 3-WAY ECONOSEAL III LC / RED
ENGINE COMPARTMENT / RIGHT FRONT
RELAYS
Relay
Case Color
Connector / Color
Location / Access
STARTER RELAY
BROWN
EM50 / BROWN
CONTROL MODULE ENCLOSURE RELAYS / ENGINE COMPARTMENT
HARNESS-TO-HARNESS CONNECTORS
Connector
Type / Color
Location / Access
EM2
20-WAY MULTILOCK 070 / GREY
PASSENGER ‘A’ POST / LOWER ‘A’ POST FINISHER
EM3
18-WAY MULTILOCK 070 / WHITE
PASSENGER ‘A’ POST / LOWER ‘A’ POST FINISHER
EM60
2-WAY ECONOSEAL J2 / GREY
ENGINE COMPARTMENT / ADJACENT RH TO FALSE BULKHEAD
FC7
20-WAY MULTILOCK 070 / YELLOW
ABOVE DIMMER MODULE / COIN TRAY
PI1
57-WAY SUMITOMO TS090 / BLACK
ENGINE COMPARTMENT / BULKHEAD / REAR OF ENGINE
PI2
13-WAY ECONOSEAL III LC / BLACK
ENGINE COMPARTMENT / BRACKET ON TOP OF TRANSMISSION
ST5
EYELET
ENGINE COMPARTMENT / RH FALSE BULKHEAD
ST6
EYELET
ENGINE COMPARTMENT / RH FALSE BULKHEAD
GROUNDS
Ground
Location / Type
BT65
EYELET (SINGLE) – BATTERY GROUND STUD
CC3R
EYELET (PAIR) – RH FRONT BULKHEAD STUD / CABIN SIDE
FC17L
EYELET (PAIR) – EMS BULKHEAD GROUND STUD
FOR CONTROL MODULE PIN OUT INFORMATION, UNFOLD PAGE TO LEFT.
CONTROL MODULE PIN OUT INFORMATION
BODY PROCESSOR MODULE
P
Pin
Description
Active
Inactive
I
FC15-7
NEUTRAL SWITCH STATUS
GROUND (N)
B+ (P, R, D, 4, 3, 2)
D
FC15-21
SERIAL COMMUNICATION – KEY TRANSPONDER
ENCODED COMMUNICATIONS
D
FC15-39
SECURITY ACKNOWLEDGE
ENCODED COMMUNICATIONS
I
FC15-41
STARTER ENGAGE REQUEST
GROUND (CRANKING)
B+
O
FC15-73
STARTER RELAY ACTIVATE
GROUND (CRANKING)
B+
I
FC15-80
BATTERY SUPPLY VOLTAGE
B+
B+
D
FC15-92
ENCODED COMMUNICATIONS
ENGINE CONTROL MODULE
P
Pin
Description
Active
Inactive
I
EM81-12
PARK / NEUTRAL CONFIRMATION
B+ (P, N)
GROUND (R,D,4,3,2)
I
EM82-2
ENGINE CRANK
GROUND (CRANKING)
D
EM82-15
OK TO START
ENCODED COMMUNICATIONS
D
EM82-16
SECURITY ACKNOWLEDGE
ENCODED COMMUNICATIONS
KEY TRANSPONDER MODULE
P
Pin
Description
Active
Inactive
D
FC22-9
SERIAL COMMUNICATION
ENCODED COMMUNICATIONS
D
FC22-11
SERIAL COMMUNICATION – BPM
ENCODED COMMUNICATIONS
D
FC22-16
OK TO START
ENCODED COMMUNICATIONS
D
FC22-17
SECURITY ACKNOWLEDGE
ENCODED COMMUNICATIONS
The following abbreviations are used to represent values for Control Module Pin-Out data
I
Input
D
Serial and Encoded Data
B+
Battery Voltage
kHz
Frequency x 1000
O
Output
C
CAN (Network)
V
Voltage (DC)
ms
Milliseconds
SG
Signal Ground
S
SCP Network
Hz
Frequency
mV
Millivolts
CAUTION: The information on this data page is furnished to aid the user in understanding circuit operation.
THIS INFORMATION SHOULD BE USED FOR
REFERENCE ONLY.
NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all
components connected and fitted.
“Active” means a load is applied or a switch is ON; “Inactive” means a load is not applied or a switch is OFF.
Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, grounds, control
modules and control module pins.
DATE OF ISSUE:
October 1999
Fig. 03.2
COMPONENTS
Component
Connector / Type / Color
Location / Access
BATTERY
BT66 / BATTERY CABLE CLAMP
TRUNK / BATTERY COVER
BT67 / BATTERY CABLE CLAMP
BODY PROCESSOR MODULE
FC15 / 14-WAY AMP EEEC / GREY
BULKHEAD / BEHIND GLOVE BOX
DUAL LINEAR SWITCH
CC8 / 12-WAY MULTILOCK 070 / GREY
RIGHT HAND SIDE OF GEAR SELECTOR / CENTER CONSOLE
ENGINE CONTROL MODULE
EM80 / 31-WAY AMP 403 / NATURAL
ENGINE COMPARTMENT / CONTROL MODULE ENCLOSURE
EM81 / 24-WAY AMP 403 / NATURAL
EM82 / 17-WAY AMP 403 / NATURAL
EM83 / 28-WAY AMP 403 / NATURAL
EM84 / 22-WAY AMP 403 / NATURAL
EM85 / 12-WAY MULTILOCK 070 / WHITE
GENERATOR
AN1 / EYELET
ENGINE COMPARTMENT / RH FRONT
AN2 / EYELET
ST4 / EYELET
HIGH POWER PROTECTION MODULE
BT60 / EYELET
TRUNK / ADJACENT TO BATTERY
BT61 / EYELET
BT62 / EYELET
BT63 / EYELET
IGNITION SWITCH
FC4 / 8-WAY MULTILOCK 070 / WHITE
STEERING COLUMN
KEY TRANSPONDER MODULE
FC22 / 20-WAY MULTILOCK 040 / GREEN
BELOW INSTRUMENT PACK
REGULATOR (GENERATOR)
PI50 / 3-WAY SUMITOMO 92 / BLACK
ENGINE COMPARTMENT / RH FRONT
STARTER MOTOR
ST1 / EYELET
ENGINE COMPARTMENT / ENGINE BLOCK / RH SIDE
ST2 / EYELET
ST3 / EYELET
SUPPRESSION MODULE
AN3 / 3-WAY ECONOSEAL III LC / RED
ENGINE COMPARTMENT / RIGHT FRONT
RELAYS
Relay
Case Color
Connector / Color
Location / Access
STARTER RELAY
BROWN
EM50 / BROWN
CONTROL MODULE ENCLOSURE RELAYS / ENGINE COMPARTMENT
HARNESS-TO-HARNESS CONNECTORS
Connector
Type / Color
Location / Access
EM2
20-WAY MULTILOCK 070 / GREY
PASSENGER ‘A’ POST / LOWER ‘A’ POST FINISHER
EM3
18-WAY MULTILOCK 070 / WHITE
PASSENGER ‘A’ POST / LOWER ‘A’ POST FINISHER
EM60
2-WAY ECONOSEAL J2 / GREY
ENGINE COMPARTMENT / ADJACENT RH TO FALSE BULKHEAD
EM63
14-WAY MULTILOCK 070 / YELLOW
PASSENGER ‘A’ POST / LOWER ‘A’ POST FINISHER
FC7
20-WAY MULTILOCK 070 / YELLOW
ABOVE DIMMER MODULE / COIN TRAY
PI1
57-WAY SUMITOMO TS090 / BLACK
ENGINE COMPARTMENT / BULKHEAD / REAR OF ENGINE
PI2
13-WAY ECONOSEAL III LC / BLACK
ENGINE COMPARTMENT / BRACKET ON TOP OF TRANSMISSION
ST5
EYELET
ENGINE COMPARTMENT / RH FALSE BULKHEAD
ST6
EYELET
ENGINE COMPARTMENT / RH FALSE BULKHEAD
GROUNDS
Ground
Location / Type
BT65
EYELET (SINGLE) – BATTERY GROUND STUD
FC17L
EYELET (PAIR) – EMS BULKHEAD GROUND STUD
EM8R
EYELET (PAIR) – EMS LH GROUND STUD
FOR CONTROL MODULE PIN OUT INFORMATION, UNFOLD PAGE TO LEFT.
CONTROL MODULE PIN OUT INFORMATION
BODY PROCESSOR MODULE
P
Pin
Description
Active
Inactive
I
FC15-7
NEUTRAL SWITCH STATUS
GROUND (N)
B+ (P, R, D, 4, 3, 2)
D
FC15-21
SERIAL COMMUNICATION – KEY TRANSPONDER
ENCODED COMMUNICATIONS
D
FC15-39
SECURITY ACKNOWLEDGE
ENCODED COMMUNICATIONS
I
FC15-41
STARTER ENGAGE REQUEST
GROUND (CRANKING)
B+
O
FC15-73
STARTER RELAY ACTIVATE
GROUND (CRANKING)
B+
I
FC15-80
BATTERY SUPPLY VOLTAGE
B+
B+
D
FC15-92
ENCODED COMMUNICATIONS
ENGINE CONTROL MODULE
P
Pin
Description
Active
Inactive
I
EM81-12
PARK / NEUTRAL CONFIRMATION
B+ (P, N)
GROUND (R,D,4,3,2)
I
EM82-2
ENGINE CRANK
GROUND (CRANKING)
D
EM82-15
OK TO START
ENCODED COMMUNICATIONS
D
EM82-16
SECURITY ACKNOWLEDGE
ENCODED COMMUNICATIONS
KEY TRANSPONDER MODULE
P
Pin
Description
Active
Inactive
D
FC22-9
SERIAL COMMUNICATION
ENCODED COMMUNICATIONS
D
FC22-11
SERIAL COMMUNICATION – BPM
ENCODED COMMUNICATIONS
D
FC22-16
OK TO START
ENCODED COMMUNICATIONS
D
FC22-17
SECURITY ACKNOWLEDGE
ENCODED COMMUNICATIONS
DUAL LINEAR SWITCH
P
Pin
Description
Active
Inactive
I
CC8-2
TCM / DUAL LINEAR SWITCH COMMON GROUND SUPPLY
GROUND
GROUND
O
CC8-4
NEUTRAL SWITCH STATUS
GROUND (N)
B+ (P, R, D, 4, 3, 2)
O
CC8-11
PARK / NEUTRAL CONFIRMATION
B+ (P, N)
GROUND (R, D, 4, 3, 2)
|
|
|