Nissan Juke (2016 year). Service Repair Manual - part 489

MA-6

< PERIODIC MAINTENANCE >

GENERAL MAINTENANCE

UNDER THE HOOD AND VEHICLE

The maintenance items listed here should be checked periodically (e.g. each time you check the engine oil or refuel).

Seats

Check seat position controls such as seat adjusters, seatback recliner, etc. to make 
sure they operate smoothly and that all latches lock securely in every position. Check 
that the head restraints move up and down smoothly and that the locks (if equipped) 
hold securely in all latched positions. Check that the latches lock securely for folding-
down rear seatbacks.

—

Seat belts

Check that all parts of the seat belt system (e.g. buckles, anchors, adjusters and re-
tractors) operate properly and smoothly and are installed securely. Check the belt 
webbing for cuts, fraying, wear or damage.

MA-47

Accelerator pedal

Check the pedal for smooth operation and make sure the pedal does not catch or re-
quire uneven effort. Keep the floor mats away from the pedal.

—

Brakes

Check that the brake does not pull the vehicle to one side when applied.

—

Brake pedal and 
booster

Check the pedal for smooth operation and make sure it has the proper distance under 
it when depressed fully. Check the brake booster function. Be sure to keep floor mats 
away from the pedal.

BR-9

BR-15

Clutch pedal

Make sure the pedal operates smoothly and check that it has the proper free play.

CL-6

Parking brake

Check that the lever or pedal has the proper travel and make sure that the vehicle is 
held securely on a fairly steep hill when only the parking brake is applied.

PB-4

CVT P (Park) position 
mechanism

On a fairly steep hill check that the vehicle is held securely with the selector lever in 
the “P” position without applying any brakes.

—

Item

Reference page

Item

Reference page

Windshield washer 
fluid

Check that there is adequate fluid in the tank.

—

Engine coolant level

Check the coolant level when the engine is cold.

MA-16
MA-26

Radiator and hoses

Check the front of the radiator and clean off any dirt, insects, leaves, etc., that may 
have accumulated. Make sure the radiator hoses have no cracks, deformation, dete-
rioration or loose connections.

MA-20

Brake and clutch fluid 
levels

Make sure that the brake and clutch fluid level(s) are(is) between the “MAX” and “MIN” 
lines on the reservoir(s).

MA-43
MA-38

Battery

Check the fluid level in each cell. It should be between the “MAX” and “MIN” lines. Ve-
hicles operated in high temperatures or under severe conditions require frequent 
checks of the battery fluid level.

PG-97

Engine drive belts

Make sure that no belt is frayed, worn, cracked or oily.

MA-15
MA-25

Engine oil level

Check the level on the oil level gauge after parking the vehicle on a level spot and turn-
ing off the engine.

LU-9

LU-28

Exhaust system

Make sure there are no loose supports, cracks or holes. If the sound of the exhaust 
seems unusual or there is a smell of exhaust fumes, immediately locate the trouble 
and correct it.

MA-35

Underbody

The underbody is frequently exposed to corrosive substances such as those used on 
icy roads or to control dust. It is very important to remove these substances, otherwise 
rust will form on the floor pan, frame, fuel lines and around the exhaust system. At the 
end of winter, the underbody should be thoroughly flushed with plain water, being 
careful to clean those areas where mud and dirt can easily accumulate.

—

Fluid leaks

Check under the vehicle for fuel, oil, water or other fluid leaks after the vehicle has 
been parked for a while. Water dripping from the air conditioner after use is normal. If 
you should notice any leaks or gasoline fumes are evident, check for the cause and 
correct it immediately.

—

Revision: November 2015

2016 JUKE

PERIODIC MAINTENANCE

MA-7

< PERIODIC MAINTENANCE >

C

D

E

F

G

H

I

J

K

L

M

B

MA

N

O

A

PERIODIC MAINTENANCE

Introduction of Periodic Maintenance

INFOID:0000000012200177

The following tables show the normal maintenance schedule. Depending upon weather and atmospheric con-

ditions, varying road surfaces, individual driving habits and vehicle usage, additional or more frequent mainte-

nance may be required.

Periodic maintenance beyond the last period shown on the tables requires similar maintenance.

Emission Control System Maintenance

Abbreviations: R = Replace. I = Inspect. Correct or replace if necessary.

MAINTENANCE OPERATION

MAINTENANCE INTERVAL

Perform at number of miles, kilometers 
or months, whichever comes first.

Miles x 1,000

(km x 1,000)

Months

5

(8)

6

10

(16)

12

15

(24)

18

20

(32)

24

25

(40)

30

30

(48)

36

35

(56)

42

40

(64)

48

45

(72)

54

Drive belt

NOTE (1)

I*

Air cleaner filter

NOTE (2)

R

EVAP vapor lines

I*

I*

Fuel lines

I*

I*

Fuel filter

NOTE (3)

Engine coolant*

NOTE (4)(5)

Engine  oil

R

R

R

R

R

R

R

R

R

Engine oil filter (Use genuine NISSAN 
engine oil filter or equivalent)

R

R

R

R

R

R

R

R

R

Spark plugs (Iridium/platinum-tipped 
type)

NOTE (6)

Replace every 105,000 miles (168,000 km)

Intake and exhaust valve clearance* 

NOTE (7)

MAINTENANCE OPERATION

MAINTENANCE INTERVAL

Perform at number of miles, kilometers 
or months, whichever comes first.

Miles x 1,000

(km x 1,000)

Months

50

(80)

60

55

(88)

66

60

(96)

72

65

(104)

78

70

(112)

84

75

(120)

90

80

(128)

96

85

(136)

102

90

(144)

108

Drive  belt

NOTE  (1)

I*

I*

I*

I*

I*

Air cleaner filter

NOTE (2)

R

R

EVAP vapor lines

I*

I*

Fuel lines

I*

I*

Fuel filter

NOTE (3)

Engine coolant*

NOTE (4)(5)

Engine oil

R

R

R

R

R

R

R

R

R

Engine oil filter (Use genuine NISSAN 
engine oil filter or equivalent)

R

R

R

R

R

R

R

R

R

Spark plugs (Iridium/platinum-tipped 
type)

NOTE (6)

Replace every 105,000 miles (168,000 km)

Intake and exhaust valve clearance* 

NOTE (7)

Revision: November 2015

2016 JUKE

MA-8

< PERIODIC MAINTENANCE >

PERIODIC MAINTENANCE

NOTE:

• (1) After 40,000 miles (64,000 km) or 48 months, inspect every 10,000 miles (16,000 km) or 12 months. Replace the drive belts if

found damaged.

• (2) If operating mainly in dusty conditions, more frequent maintenance may be required.
• (3) Maintenance-free item. For service procedures, refer to the FL section.
• (4) First replacement interval is 105,000 miles (168,000 km) or 84 months. After first replacement, replace every 75,000 miles

(120,000 km) or 60 months. 

• (5) Use only Genuine NISSAN Long Life Antifreeze/Coolant (blue) or equivalent with proper mixture ratio of 50% anti-freeze and 50%

demineralized or distilled water. Mixing any other type of coolant or the use of non-distilled water will reduce the life expectancy of the
factory fill coolant.

• (6) Replace spark plug when the plug gap exceeds 1.1 mm (0.043 in) even if within specified periodic replacement mileage.
• (7) Periodic maintenance is not required. However, if valve noise increases, inspect valve clearance.
* Maintenance items and intervals with “*” are recommended by NISSAN for reliable vehicle operation. The owner need not perform
such maintenance in order to maintain the emission warranty or manufacturer recall liability. Other maintenance items and intervals are
required.

Chassis and Body Maintenance

Abbreviations: R = Replace. I = Inspect. Correct or replace if necessary.

MAINTENANCE OPERATION

MAINTENANCE INTERVAL

Reference Page

Perform at number of miles, kilometers 
or months, whichever comes first.

Miles x 1,000

(km x 1,000)

Months

95

(152)

114

100

(160)

120

105

(168)

126

110

(176)

132

115

(184)

138

120

(192)

144

Drive belt

NOTE (1)

I*

I*

I*

MA-15
MA-25

Air cleaner filter

NOTE (2)

R

MA-20
MA-31

EVAP vapor lines

I*

I*

MA-24
MA-34

Fuel lines

I*

I*

MA-20
MA-31

Fuel filter

NOTE (3)

—

Engine coolant*

NOTE (4)(5)

MA-16
MA-26

Engine  oil

R

R

R

R

R

R

MA-21
MA-32

Engine oil filter (Use genuine NISSAN 
engine oil filter or equivalent)

R

R

R

R

R

R

MA-22
MA-32

Spark plugs (Iridium/platinum-tipped 
type)

NOTE (6)

Replace every 105,000 miles (168,000 km)

MA-23
MA-33

Intake and exhaust valve clearance* 

NOTE (7)

EM-14

EM-179

MAINTENANCE OPERATION

MAINTENANCE INTERVAL

Perform at number of miles, kilome-
ters or months, whichever comes 
first.

Miles x 1,000

(km x 1,000)

Months

5

(8)

6

10

(16)

12

15

(24)

18

20

(32)

24

25

(40)

30

30

(48)

36

35

(56)

42

40

(64)

48

45

(72)

54

Brake lines & cables

I

I

I

I

Brake pads & rotors

I

I

I

I

Brake fluid

R

R

CVT  fluid

NOTE  (1)

I

I

I

I

Manual transaxle gear oil

NOTE (2)

I

I

I

I

Transfer fluid and differential gear oil

NOTE (2)

I

I

I

I

Steering gear & linkage, axle & sus-
pension parts

I

I

Revision: November 2015

2016 JUKE

PERIODIC MAINTENANCE

MA-9

< PERIODIC MAINTENANCE >

C

D

E

F

G

H

I

J

K

L

M

B

MA

N

O

A

Tire rotation

NOTE (3)

Propeller shaft (AWD) & drive shaft 
boots

I

I

I

I

Exhaust system

I

I

In-cabin microfilter

R

R

R

I-key battery

R

R

R

MAINTENANCE OPERATION

MAINTENANCE INTERVAL

Perform at number of miles, kilome-
ters or months, whichever comes 
first.

Miles x 1,000

(km x 1,000)

Months

5

(8)

6

10

(16)

12

15

(24)

18

20

(32)

24

25

(40)

30

30

(48)

36

35

(56)

42

40

(64)

48

45

(72)

54

MAINTENANCE OPERATION

MAINTENANCE INTERVAL

Perform at number of miles, kilome-
ters or months, whichever comes 
first.

Miles x 1,000

(km x 1,000)

Months

50

(80)

60

55

(88)

66

60

(96)

72

65

(104)

78

70

(112)

84

75

(120)

90

80

(128)

96

85

(136)

102

90

(144)

108

Brake  lines  &  cables

I

I

I

I

I

Brake pads & rotors

I

I

I

I

I

Brake fluid

R

R

CVT  fluid

NOTE  (1)

I

I

I

I

I

Manual  transaxle  gear  oil

NOTE  (2)

I

I

I

I

I

Transfer  fluid  and  differential  gear  oil

NOTE  (2)

I

I

I

I

I

Steering gear & linkage, axle & sus-
pension parts

I

I

Tire rotation

NOTE (3)

Propeller shaft (AWD) & drive shaft 
boots

I

I

I

I

I

Exhaust system

I

I

In-cabin microfilter

R

R

R

I-key battery

R

R

R

MAINTENANCE OPERATION

MAINTENANCE INTERVAL

Reference Page

Perform at number of miles, kilometers 
or months, whichever comes first.

Miles x 1,000

(km x 1,000)

Months

95

(152)

114

100

(160)

120

105

(168)

126

110

(176)

132

115

(184)

138

120

(192)

144

Brake lines & cables

I

I

I

MA-44

Brake pads & rotors

I

I

I

MA-44

Brake fluid

R

R

MA-44

CVT  fluid

NOTE  (1)

I

I

I

MA-35
MA-36

Manual transaxle gear oil

NOTE (2)

I

I

I

MA-36
MA-37

Transfer fluid and differential gear oil

NOTE (2)

I

I

I

MA-39
MA-41

Steering gear & linkage, axle & sus-
pension parts

I

I

MA-46
MA-46

Tire rotation

NOTE (3)

MA-5

MA-43

Propeller shaft (AWD) & drive shaft 
boots

I

I

I

MA-40
MA-46

Revision: November 2015

2016 JUKE

MA-10

< PERIODIC MAINTENANCE >

PERIODIC MAINTENANCE

NOTE:

•

Maintenance items with “ ” should be performed more frequently according to “Maintenance Under Severe Driving Condi-
tions”.

• (1) If towing a trailer, using a camper or a car-top carrier or driving on rough or muddy roads, inspect CVT fluid deterioration at NIS-

SAN dealer every 60,000 miles (96,000 km), then change CVT fluid if necessary. And if the inspection is not performed, change (not
just inspect) CVT fluid every 60,000 miles (96,000 km). For Recommended Fluids and Lubricants, see “RECOMMENDED FLUIDS
AND LUBRICANTS” (Refer to 

MA-11

). 

• (2) If towing a trailer, using a camper or car-top carrier, or driving on rough or muddy roads, change (not just inspect) oil at every

20,000 miles (32,000 km) or 24 months.

• (3) Refer to “Tire rotation” under the “GENERAL MAINTENANCE” heading earlier in this section.

MAINTENANCE UNDER SEVERE DRIVING CONDITIONS

The maintenance intervals shown on the preceding pages are for normal operating conditions. If the vehicle is

mainly operated under severe driving conditions as shown below, more frequent maintenance must be per-

formed on the following items as shown in the table.

Severe driving conditions

• Repeated short trips of less than 5 miles (8 km).

• Repeated short trips of less than 10 miles (16 km) with outside temperatures remaining below freezing.

• Operating in hot weather in stop-and-go “rush hour” traffic.

• Extensive idling and/or low speed driving for long distances, such as police, taxi or door-to-door delivery use.

• Driving in dusty conditions.

• Driving on rough, muddy, or salt spread roads.

• Towing a trailer, using a camper or a car-top carrier.

Maintenance operation: Inspect = Inspect and correct or replace as necessary.

Exhaust system

I

I

MA-35

In-cabin microfilter

R

R

VTL-16

I-key battery

R

R

DLK-175

MAINTENANCE OPERATION

MAINTENANCE INTERVAL

Reference Page

Perform at number of miles, kilometers 
or months, whichever comes first.

Miles x 1,000

(km x 1,000)

Months

95

(152)

114

100

(160)

120

105

(168)

126

110

(176)

132

115

(184)

138

120

(192)

144

Maintenance item

Maintenance 

operation

Maintenance interval

Reference page

Brake fluid

Replace

Every 10,000 miles (16,000 km) 
or 12 months

MA-44

Brake pads & rotors

Inspect

Every 5,000 miles (8,000 km) or 
6 months

MA-44

Steering gear & linkage, axle & suspension parts

Inspect

Every 5,000 miles (8,000 km) or 
6 months

MA-46
MA-46

Propeller shaft (AWD) & drive shaft boots

Inspect

Every 5,000 miles (8,000 km) or 
6 months

MA-40
MA-46

Exhaust system

Inspect

Every 5,000 miles (8,000 km) or 
6 months

MA-35

Revision: November 2015

2016 JUKE

RECOMMENDED FLUIDS AND LUBRICANTS

MA-11

< PERIODIC MAINTENANCE >

C

D

E

F

G

H

I

J

K

L

M

B

MA

N

O

A

RECOMMENDED FLUIDS AND LUBRICANTS

Fluids and Lubricants

INFOID:0000000012200178

The following are approximate capacities. The actual refill capacities may be slightly different. When refilling,

follow the procedures described elsewhere in this manual.

Fluid types

Capacity (Approximate)

Recommended Fluids/Lubricants

Liter

US mea-

sure

Imp mea-

sure

Fuel

2WD models

50.0

13-1/4 gal

11 gal

Unleaded gasoline with an octane rat-
ing of at least 87 AKI (RON 91)

AWD models

45.0

11-7/8 gal

9-7/8 gal

Engine oil
Drain and refill

With oil filter 
change

For NISMO RS 
models

4.5

4-6/8 qt

4 qt

For NISMO RS models:
• Genuine NISSAN engine oil or 

equivalent

• Engine oil with API Certification 

Mark*

1

, Viscosity SAE 5W-30*

2

*1: For additional information, see “En-
gine Oil Recommendation”.
*2: As an alternative to this recom-
mended oil, SAE 5W-30 or SAE 10W-
30 conventional petroleum based oils 
may be used and meet all specifica-
tions and requirements necessary to 
maintain the New Vehicle Limited War-
ranty.
Except for NISMO RS models:
• Genuine NISSAN engine oil or 

equivalent

• Engine oil with API Certification 

Mark*

3

, Viscosity SAE 0W-20*

4

*3: For additional information, see “En-
gine Oil Recommendation”.
*4: As an alternative to this recom-
mended oil, SAE 5W-30 conventional 
petroleum based oils may be used and 
meet all specifications and require-
ments necessary to maintain the New 
Vehicle Limited Warranty.

Except for NISMO 
RS models

4.3

4-4/8 qt

3-6/8 qt

Without oil filter 
change

For NISMO RS 
models

4.3

4-4/8 qt

3-6/8 qt

Except for NISMO 
RS models

4.1

4-3/8 qt

3-5/8 qt

Dry engine (engine overhaul)

For NISMO RS 
models

5.4

5-6/8 qt

4-6/8 qt

Except for NISMO 
RS models

5.2

5-4/8 qt

4-5/8 qt

Engine coolant

With reservoir 
tank

For NISMO RS 
models (M/T)

7.9

8-3/8 qt

7 qt

• Pre-diluted Genuine NISSAN Long 

Life Anti freeze / Coolant (blue) or 
equivalent

For NISMO RS 
models (CVT)

8.1

8-1/2 qt

7-1/8 qt

Except for NISMO 
RS models (M/T)

8.5

9 qt

7-1/2 qt

Except for NISMO 
RS models (CVT)

8.7

9-2/8 qt

7-5/8 qt

Reservoir tank

0.6

5/8 qt

1/2 qt

Revision: November 2015

2016 JUKE

MA-12

< PERIODIC MAINTENANCE >

RECOMMENDED FLUIDS AND LUBRICANTS

Manual transaxle fluid 
(MTF)

RS6F94R

2.0

4-1/4 pt

3-1/2 pt

For NISMO RS models:
• Genuine NISSAN Manual Transmis-

sion Fluid (MTF) HQ Multi 75W-85 
or equivalent

• If Genuine NISSAN Manual Trans-

mission Fluid (MTF) HQ Multi 75W-
85 is hard to obtain, API GL-4, Vis-
cosity SAE 75W-85 may be used as 
a temporary replacement. However, 
use Genuine NISSAN gear oil as 
soon as it is available.

Except for NISMO RS models:
• Genuine NISSAN Manual Transmis-

sion Fluid (MTF) TL/JR Type 75W-
80 or equivalent

• If Genuine NISSAN Manual Trans-

mission Fluid (MTF) TL/JR Type is 
not available, API GL-4+, Viscosity 
SAE 75W-80 may be used as a tem-
porary replacement. However, use 
Genuine NISSAN Manual Transmis-
sion Fluid (MTF) TL/JR Type as 
soon as it is available.

RS6F52H

1.9

4 pt

3-3/8 pt

CVT fluid

RE0F10B

8.6

9-1/8 qt

7-5/8 qt

For NISMO RS models:
• Genuine NISSAN CVT Fluid NS-2
• NISSAN recommends using Genu-

ine NISSAN CVT Fluid NS-2 ONLY 
in NISSAN CVTs. Do not mix with 
other fluids. Using fluids that are not 
equivalent to Genuine NISSAN CVT 
Fluid NS-2 may damage the CVT. 
Damage caused by the use of fluids 
other than as recommended is not 
covered under NISSAN's New Vehi-
cle Limited Warranty.

Except for NISMO RS models:
• Genuine NISSAN CVT Fluid NS-3
• NISSAN recommends using Genu-

ine NISSAN CVT Fluid NS-3 ONLY 
in NISSAN CVTs. Do not mix with 
other fluids. Using fluids that are not 
equivalent to Genuine NISSAN CVT 
Fluid NS-3 may damage the CVT. 
Damage caused by the use of fluids 
other than as recommended is not 
covered under NISSAN's New Vehi-
cle Limited Warranty.

RE0F10D

7.9

8-3/8 qt

7 qt

Transfer fluid

0.37

3/4 pt

5/8 pt

• Genuine NISSAN Differential Oil 

Hypoid Super GL-5 80W-90 or 
equivalent conventional (non-syn-
thetic) oil

Differential gear oil

0.4

7/8 pt

3/4 pt

Brake and clutch fluid

—

—

—

• Genuine NISSAN Super Heavy 

Duty Brake Fluid*

5

 or equivalent 

DOT 3 (US FMVSS No. 116)

*5: Available in mainland U.S.A. 
through a NISSAN dealer.

Multi-purpose grease

—

—

—

• NLGI No. 2 (Lithium soap base)

Windshield washer fluid

4.5

4-3/4 qt

4 qt

• Genuine NISSAN Windshield 

Washer Concentrate Cleaner & 
Anti-Freeze or equivalent

Fluid types

Capacity (Approximate)

Recommended Fluids/Lubricants

Liter

US mea-

sure

Imp mea-

sure

Revision: November 2015

2016 JUKE

RECOMMENDED FLUIDS AND LUBRICANTS

MA-13

< PERIODIC MAINTENANCE >

C

D

E

F

G

H

I

J

K

L

M

B

MA

N

O

A

SAE Viscosity Number

INFOID:0000000012200179

NISSAN recommends the use of an energy conserving oil in order to improve fuel economy.

Select only engine oils that meet the American Petroleum Institute (API) certification and International Lubrica-

tion Standardization and Approval Committee (ILSAC) certification and SAE viscosity standard. These oils

have the API certification mark on the front of the container. Oils which do not have the specified quality label

should not be used as they could cause engine damage.

• For NISMO RS models

• Except for NISMO RS models

Anti-Freeze Coolant Mixture Ratio

INFOID:0000000012200180

The engine cooling system is filled at the factory with a pre-diluted mixture of 50% Genuine NISSAN Long Life

Antifreeze/Coolant (blue) and 50% water to provide year-round anti-freeze and coolant protection. The anti-

freeze solution contains rust and corrosion inhibitors. Additional engine cooling system additives are not nec-

essary.

WARNING:

• Never remove the radiator or coolant reservoir cap when the engine is hot. Wait until the engine and

radiator cool down. Serious burns could be caused by high pressure fluid escaping from the radia-

tor. 

Air conditioning system refrigerant

0.40 

±

 

0.05 kg

0.88 

±

 

0.10 lb

0.88 

±

 

0.10 lb

• HFC-134a (R-134a)
• For further details, see “Air condi-

tioner specification label”.

Air conditioning system oil

120 m

4.1 fl oz

4.2 fl oz

• A/C System Oil Type R (DH-PR) 
• For further details, see “Air condi-

tioner specification label”.

Fluid types

Capacity (Approximate)

Recommended Fluids/Lubricants

Liter

US mea-

sure

Imp mea-

sure

JSPIA0014ZZ

1.

API certification mark

2.

API service symbol

ALPIA0008ZZ

1.

API certification mark

2.

API service symbol

Revision: November 2015

2016 JUKE