Nissan Juke (2016 year). Service Repair Manual - part 102

FILAMENT

DEF-43

< REMOVAL AND INSTALLATION >

C

D

E

F

G

H

I

J

K

M

A

B

DEF

N

O

P

REMOVAL AND INSTALLATION

FILAMENT

Inspection and Repair

INFOID:0000000012196862

INSPECTION

1. When measuring voltage, wrap tin foil around the top of the neg-

ative probe. Then press the foil against the wire with your finger.

2. Attach probe circuit tester (in Volt range) to middle portion of

each filament.

3. If a filament is burned out, circuit tester registers 0 or battery

voltage.

4. To locate burned out point, move probe to left and right along fil-

ament. Test needle will swing abruptly when probe passes the

point.

REPAIR

REPAIR EQUIPMENT

• Conductive silver composition (Dupont No. 4817 or equivalent)

SEL122R

SEL263

SEL265

Revision: November 2015

2016 JUKE

DEF-44

< REMOVAL AND INSTALLATION >

FILAMENT

• Ruler 30 cm (11.8 in) long

• Drawing pen

• Heat gun

• Alcohol

• Cloth

REPAIRING PROCEDURE

1. Wipe broken heat wire and its surrounding area clean with a

cloth dampened in alcohol.

2. Apply a small amount of conductive silver composition to tip of

drawing pen.

Shake silver composition container before use.

3. Place ruler on glass along broken line. Deposit conductive silver

composition on break with drawing pen. Slightly overlap existing

heat wire on both sides [preferably 5 mm (0.20 in)] of the break.

4. After repair has been completed, check repaired wire for conti-

nuity. This check should be conducted 10 minutes after silver

composition is deposited.

Do not touch repaired area while test is being conducted.

5. Apply a constant stream of hot air directly to the repaired area

for approximately 20 minutes with a heat gun. A minimum dis-

tance of 3 cm (1.2 in) should be kept between repaired area and

hot air outlet.

If a heat gun is not available, let the repaired area dry for 24

hours.

PIIA0215E

SEL012D

SEL013D

Revision: November 2015

2016 JUKE

CONDENSER

DEF-45

< REMOVAL AND INSTALLATION >

C

D

E

F

G

H

I

J

K

M

A

B

DEF

N

O

P

CONDENSER

Exploded View

INFOID:0000000012196863

Refer to 

INT-38, "Exploded View"

.

Removal and Installation

INFOID:0000000012196864

REMOVAL

1. Remove the back door lower finisher.

Refer to 

INT-39, "BACK DOOR LOWER FINISHER : Removal and Installation"

.

2. Remove bolt (A), and then remove condenser (1) from the vehi-

cle body.

INSTALLATION

Install in the reverse order of removal.

JMLIA1275ZZ

Revision: November 2015

2016 JUKE

DLK-1

BODY EXTERIOR, DOORS, ROOF & VEHICLE SECURITY

C

D

E

F

G

H

I

J

L

M

SECTION 

DLK

A

B

DLK

N

O

P

CONTENTS

DOOR & LOCK

WITH INTELLIGENT KEY SYSTEM

PRECAUTION ...............................................

6

PRECAUTIONS ...................................................

6

Precaution for Supplemental Restraint System 
(SRS) "AIR BAG" and "SEAT BELT PRE-TEN-
SIONER" ...................................................................

6

Precaution for Procedure without Cowl Top Cover 

......

6

Precautions For Xenon Headlamp Service  ...............

6

Precautions for Removing Battery Terminal  .............

7

Work ..........................................................................

7

PREPARATION ............................................

8

PREPARATION ...................................................

8

Special Service Tools ................................................

8

Commercial Service Tools  ........................................

8

SYSTEM DESCRIPTION  ..............................

9

COMPONENT PARTS  ........................................

9

Component Parts Location ......................................

9

Component Description ..........................................

10

SYSTEM (POWER DOOR LOCK SYSTEM)  .....

11

System Diagram ......................................................

11

System Description  .................................................

11

SYSTEM (INTELLIGENT KEY SYSTEM)  ..........

13

INTELLIGENT KEY SYSTEM  ...................................

13

INTELLIGENT KEY SYSTEM : System Diagram ....

13

INTELLIGENT KEY SYSTEM : System Descrip-
tion ..........................................................................

13

DOOR LOCK FUNCTION ..........................................

14

DOOR LOCK FUNCTION : System Diagram  .........

14

DOOR LOCK FUNCTION : System Description  .....

14

BACK DOOR OPEN FUNCTION  ..............................

16

BACK DOOR OPEN FUNCTION : System Dia-
gram ........................................................................

16

BACK DOOR OPEN FUNCTION : System De-
scription ...................................................................

16

REMOTE KEYLESS ENTRY FUNCTION ..................

17

REMOTE KEYLESS ENTRY FUNCTION : Sys-
tem Diagram  ............................................................

18

REMOTE KEYLESS ENTRY FUNCTION : Sys-
tem Description ........................................................

18

KEY REMINDER FUNCTION  ....................................

20

KEY REMINDER FUNCTION : System Diagram ....

20

KEY REMINDER FUNCTION : System Descrip-
tion ...........................................................................

20

WARNING FUNCTION  ..............................................

21

WARNING FUNCTION : System Description ..........

21

BACK DOOR OPENER SYSTEM .....................

24

System Diagram  ......................................................

24

System Description ..................................................

24

DIAGNOSIS SYSTEM (BCM)  ...........................

25

COMMON ITEM  .........................................................

25

COMMON ITEM : CONSULT Function (BCM - 
COMMON ITEM)  .....................................................

25

DOOR LOCK ..............................................................

26

DOOR LOCK : CONSULT Function (BCM - 
DOOR LOCK) ..........................................................

26

INTELLIGENT KEY ....................................................

27

INTELLIGENT KEY : CONSULT Function (BCM - 
INTELLIGENT KEY)  ................................................

28

TRUNK .......................................................................

31

TRUNK : CONSULT Function (BCM - TRUNK)  ......

31

ECU DIAGNOSIS INFORMATION ..............

32

BCM ...................................................................

32

List of ECU Reference .............................................

32

WIRING DIAGRAM ......................................

33

Revision: November 2015

2016 JUKE

DLK-2

DOOR & LOCK SYSTEM  ..................................

33

Wiring Diagram  .......................................................

33

BASIC INSPECTION ...................................

46

DIAGNOSIS AND REPAIR WORK FLOW ........

46

Work Flow ...............................................................

46

DTC/CIRCUIT DIAGNOSIS .........................

49

B2621 INSIDE ANTENNA  .................................

49

DTC Logic ...............................................................

49

Diagnosis Procedure  ..............................................

49

B2622 INSIDE ANTENNA  .................................

51

DTC Logic ...............................................................

51

Diagnosis Procedure  ..............................................

51

B2626 OUTSIDE ANTENNA  .............................

53

DTC Logic ...............................................................

53

Diagnosis Procedure  ..............................................

53

B2627 OUTSIDE ANTENNA  .............................

55

DTC Logic ...............................................................

55

Diagnosis Procedure  ..............................................

55

B2628 OUTSIDE ANTENNA  .............................

57

DTC Logic ...............................................................

57

Diagnosis Procedure  ..............................................

57

BACK DOOR OPENER ACTUATOR ................

59

Component Function Check .................................

59

Diagnosis Procedure  ..............................................

59

BACK DOOR OPENER SWITCH ......................

61

Component Function Check .................................

61

Diagnosis Procedure  ..............................................

61

Component Inspection ............................................

62

BACK DOOR REQUEST SWITCH ....................

63

Component Function Check .................................

63

Diagnosis Procedure  ..............................................

63

Component Inspection ............................................

64

BUZZER (COMBINATION METER)  ..................

65

Component Function Check .................................

65

Diagnosis Procedure  ..............................................

65

DOOR KEY CYLINDER SWITCH ......................

66

Component Function Check  ...................................

66

Diagnosis Procedure  ..............................................

66

Component Inspection ............................................

67

DOOR LOCK ACTUATOR  ................................

68

DRIVER SIDE ............................................................

68

DRIVER SIDE : Component Function Check ........

68

DRIVER SIDE : Diagnosis Procedure  ....................

68

PASSENGER SIDE ...................................................

69

PASSENGER SIDE : 
Component Function Check .................................

69

PASSENGER SIDE : Diagnosis Procedure  ...........

69

REAR LH  ...................................................................

70

REAR LH : Component Function Check  ...............

70

REAR LH : Diagnosis Procedure  ............................

70

REAR RH ...................................................................

71

REAR RH : Component Function Check ...............

71

REAR RH : Diagnosis Procedure  ...........................

72

DOOR LOCK AND UNLOCK SWITCH .............

73

Component Function Check ..................................

73

Diagnosis Procedure ...............................................

73

Component Inspection  ............................................

74

DOOR REQUEST SWITCH ...............................

75

Component Function Check ..................................

75

Diagnosis Procedure ...............................................

75

Component Inspection  ............................................

76

DOOR SWITCH  .................................................

77

Component Function Check ..................................

77

Diagnosis Procedure ...............................................

77

Component Inspection  ............................................

78

HAZARD FUNCTION ........................................

80

Component Function Check ..................................

80

Diagnosis Procedure ...............................................

80

INTELLIGENT KEY BATTERY  .........................

81

Component Inspection  ............................................

81

INTELLIGENT KEY WARNING BUZZER  .........

82

Component Function Check ..................................

82

Diagnosis Procedure ...............................................

82

Component Inspection  ............................................

83

KEY WARNING LAMP  ......................................

84

Component Function Check ..................................

84

Diagnosis Procedure ...............................................

84

REMOTE KEYLESS ENTRY RECEIVER  .........

85

Component Function Check ..................................

85

Diagnosis Procedure ...............................................

85

SHIFT P WARNING LAMP ................................

87

Component Function Check ..................................

87

Diagnosis Procedure ...............................................

87

UNLOCK SENSOR ............................................

88

Component Function Check ..................................

88

Diagnosis Procedure ...............................................

88

Component Inspection  ............................................

89

SYMPTOM DIAGNOSIS  ............................

90

DOOR DOES NOT LOCK/UNLOCK WITH 
DOOR LOCK AND UNLOCK SWITCH .............

90

ALL DOOR  ................................................................

90

ALL DOOR : Description .........................................

90

ALL DOOR : Diagnosis Procedure  .........................

90

DRIVER SIDE  ............................................................

90

DRIVER SIDE : Description  ....................................

90

Revision: November 2015

2016 JUKE

DLK-3

C

D

E

F

G

H

I

J

L

M

A

B

DLK

N

O

P

DRIVER SIDE : Diagnosis Procedure .....................

90

PASSENGER SIDE  ...................................................

90

PASSENGER SIDE : Description  ...........................

91

PASSENGER SIDE : Diagnosis Procedure  ............

91

REAR LH  ...................................................................

91

REAR LH : Description ............................................

91

REAR LH : Diagnosis Procedure  ............................

91

REAR RH ...................................................................

91

REAR RH : Description  ...........................................

91

REAR RH : Diagnosis Procedure ............................

91

DOOR DOES NOT LOCK/UNLOCK WITH 
DOOR REQUEST SWITCH ................................

93

ALL DOOR REQUEST SWITCHES  ..........................

93

ALL DOOR REQUEST SWITCHES : Description ....

93

ALL DOOR REQUEST SWITCHES : Diagnosis 
Procedure ................................................................

93

DRIVER SIDE DOOR REQUEST SWITCH  ...............

93

DRIVER SIDE DOOR REQUEST SWITCH : De-
scription ...................................................................

94

DRIVER SIDE DOOR REQUEST SWITCH : Diag-
nosis Procedure  ......................................................

94

PASSENGER SIDE DOOR REQUEST SWITCH  ......

94

PASSENGER SIDE DOOR REQUEST SWITCH : 
Description ..............................................................

94

PASSENGER SIDE DOOR REQUEST SWITCH : 
Diagnosis Procedure ...............................................

94

BACK DOOR REQUEST SWITCH ............................

94

BACK DOOR REQUEST SWITCH : Description ....

95

BACK DOOR REQUEST SWITCH : Diagnosis 
Procedure ................................................................

95

DOOR DOES NOT LOCK/UNLOCK WITH 
DOOR KEY CYLINDER OPERATION  ...............

96

Diagnosis Procedure ...............................................

96

DOOR DOES NOT LOCK/UNLOCK WITH IN-
TELLIGENT KEY ................................................

97

Diagnosis Procedure ...............................................

97

IGNITION POSITION WARNING FUNCTION 
DOES NOT OPERATE .......................................

99

Diagnosis Procedure ...............................................

99

SELECTIVE UNLOCK FUNCTION DOES 
NOT OPERATE  ................................................

100

Diagnosis Procedure .............................................

100

BACK DOOR DOES NOT OPENED ................

101

Diagnosis Procedure .............................................

101

AUTO DOOR LOCK OPERATION DOES NOT 
OPERATE .........................................................

102

Diagnosis Procedure .............................................

102

VEHICLE SPEED SENSING AUTO LOCK 
OPERATION DOES NOT OPERATE  .............

103

Diagnosis Procedure  .............................................

103

IGN OFF INTERLOCK DOOR UNLOCK 
FUNCTION DOES NOT OPERATE  ................

104

Diagnosis Procedure  .............................................

104

P RANGE INTERLOCK DOOR LOCK/UN-
LOCK FUNCTION DOES NOT OPERATE .....

105

Diagnosis Procedure  .............................................

105

HAZARD AND BUZZER REMINDER DOES 
NOT OPERATE ...............................................

106

Diagnosis Procedure  .............................................

106

KEY REMINDER FUNCTION DOES NOT OP-
ERATE .............................................................

108

Diagnosis Procedure  .............................................

108

OFF POSITION WARNING DOES NOT OP-
ERATE .............................................................

109

Diagnosis Procedure  .............................................

109

P POSITION WARNING DOES NOT OPER-
ATE ..................................................................

110

Diagnosis Procedure  .............................................

110

ACC WARNING DOES NOT OPERATE  ........

111

Diagnosis Procedure  .............................................

111

TAKE AWAY WARNING DOES NOT OPER-
ATE ..................................................................

112

Diagnosis Procedure  .............................................

112

INTELLIGENT KEY LOW BATTERY WARN-
ING DOES NOT OPERATE  ............................

113

Diagnosis Procedure  .............................................

113

DOOR LOCK OPERATION WARNING DOES 
NOT OPERATE ...............................................

114

Diagnosis Procedure  .............................................

114

KEY ID WARNING DOES NOT OPERATE  ....

115

Diagnosis Procedure  .............................................

115

KEY WARNING LAMP DOES NOT ILLUMI-
NATE ...............................................................

116

Diagnosis Procedure  .............................................

116

UNLOCK LINK FUNCTION DOES NOT OP-
ERATE .............................................................

117

Diagnosis Procedure  .............................................

117

SQUEAK AND RATTLE TROUBLE DIAG-
NOSES ............................................................

118

Work Flow ..............................................................

118

Inspection Procedure .............................................

120

Diagnostic Worksheet ............................................

122

REMOVAL AND INSTALLATION .............

124

Revision: November 2015

2016 JUKE

DLK-4

HOOD ...............................................................

124

Exploded View .......................................................

124

HOOD ASSEMBLY  ..................................................

124

HOOD ASSEMBLY : Removal and Installation  .....

124

HOOD ASSEMBLY : Adjustment ..........................

125

HOOD HINGE ...........................................................

126

HOOD HINGE : Removal and Installation  .............

126

HOOD HINGE : Adjustment  ..................................

127

HOOD SUPPORT ROD ............................................

129

HOOD SUPPORT ROD : Removal and Installa-
tion .........................................................................

129

RADIATOR CORE SUPPORT .........................

130

MR16DDT .................................................................

130

MR16DDT : Exploded View  ...................................

130

MR16DDT : Removal and Installation  ...................

130

FRONT FENDER  .............................................

133

Exploded View .......................................................

133

Removal and Installation  .......................................

133

FRONT DOOR  .................................................

135

Exploded View .......................................................

135

DOOR ASSEMBLY  ..................................................

135

DOOR ASSEMBLY : Removal and Installation  .....

135

DOOR ASSEMBLY : Adjustment ..........................

137

DOOR STRIKER  ......................................................

138

DOOR STRIKER : Removal and Installation  .........

138

DOOR HINGE ...........................................................

138

DOOR HINGE : Removal and Installation  .............

138

DOOR CHECK LINK ................................................

139

DOOR CHECK LINK : Removal and Installation  ...

139

REAR DOOR  ...................................................

140

Exploded View .......................................................

140

DOOR ASSEMBLY  ..................................................

140

DOOR ASSEMBLY : Removal and Installation  .....

140

DOOR ASSEMBLY : Adjustment ..........................

142

DOOR STRIKER  ......................................................

143

DOOR STRIKER : Removal and Installation  .........

143

DOOR HINGE ...........................................................

143

DOOR HINGE : Removal and Installation  .............

143

DOOR CHECK LINK ................................................

144

DOOR CHECK LINK : Removal and Installation  ...

144

BACK DOOR  ...................................................

145

Exploded View .......................................................

145

BACK DOOR ASSEMBLY .......................................

145

BACK DOOR ASSEMBLY : Removal and Installa-
tion .........................................................................

145

BACK DOOR ASSEMBLY : Adjustment ................

148

BACK DOOR STRIKER  ..........................................

150

BACK DOOR STRIKER : Removal and Installa-
tion ........................................................................

150

BACK DOOR HINGE  ..............................................

151

BACK DOOR HINGE : Removal and Installation ..

151

BACK DOOR STAY  ................................................

151

BACK DOOR STAY : Removal and Installation ....

151

BACK DOOR STAY : Disposal  .............................

152

BACK DOOR WEATHER-STRIP ............................

152

BACK DOOR WEATHER-STRIP : Removal and 
Installation .............................................................

152

HOOD LOCK  ....................................................

154

Exploded View  ......................................................

154

HOOD LOCK  ...........................................................

154

HOOD LOCK : Removal and Installation  ..............

154

HOOD LOCK CONTROL CABLE ...........................

155

HOOD LOCK CONTROL CABLE : Removal and 
Installation .............................................................

155

Inspection ..............................................................

155

FRONT DOOR LOCK .......................................

157

Exploded View  ......................................................

157

DOOR LOCK  ...........................................................

157

DOOR LOCK : Removal and Installation  ..............

157

INSIDE HANDLE  .....................................................

158

INSIDE HANDLE : Removal and Installation  ........

158

OUTSIDE HANDLE  .................................................

158

OUTSIDE HANDLE : Removal and Installation  ....

158

REAR DOOR LOCK  .........................................

161

Exploded View  ......................................................

161

DOOR LOCK  ...........................................................

161

DOOR LOCK : Removal and Installation  ..............

161

INSIDE HANDLE  .....................................................

162

INSIDE HANDLE : Removal and Installation  ........

162

OUTSIDE HANDLE  .................................................

162

OUTSIDE HANDLE : Removal and Installation  ....

162

BACK DOOR LOCK .........................................

164

Exploded View  ......................................................

164

DOOR LOCK  ...........................................................

164

DOOR LOCK : Removal and Installation  ..............

164

EMERGENCY LEVER .............................................

164

EMERGENCY LEVER : Unlock procedures .........

164

FUEL FILLER LID OPENER  ............................

166

Exploded View  ......................................................

166

FUEL FILLER LID  ...................................................

166

FUEL FILLER LID : Removal and Installation .......

166

Revision: November 2015

2016 JUKE

DLK-5

C

D

E

F

G

H

I

J

L

M

A

B

DLK

N

O

P

FUEL FILLER OPENER CABLE .............................

167

FUEL FILLER OPENER CABLE : Removal and 
Installation .............................................................

167

FUEL FILLER LID LOCK  ........................................

167

FUEL FILLER LID LOCK : Removal and Installa-
tion ........................................................................

168

DOOR SWITCH  ................................................

169

Exploded View  ......................................................

169

Removal and Installation .......................................

169

INSIDE KEY ANTENNA  ...................................

170

INSTRUMENT CENTER ..........................................

170

INSTRUMENT CENTER : Removal and Installa-
tion ........................................................................

170

LUGGAGE ROOM  ...................................................

170

LUGGAGE ROOM : Exploded View  .....................

170

LUGGAGE ROOM : Removal and Installation ......

170

OUTSIDE KEY ANTENNA ..............................

172

DRIVER SIDE ...........................................................

172

DRIVER SIDE : Removal and Installation  .............

172

PASSENGER SIDE ..................................................

172

PASSENGER SIDE : Removal and Installation  ....

172

REAR BUMPER .......................................................

172

REAR BUMPER : Removal and Installation ..........

172

INTELLIGENT KEY WARNING BUZZER .......

173

Removal and Installation  .......................................

173

REMOTE KEYLESS ENTRY RECEIVER  .......

174

Removal and Installation  .......................................

174

INTELLIGENT KEY BATTERY .......................

175

Removal and Installation  .......................................

175

Revision: November 2015

2016 JUKE