Acura TSX / Honda Accord CL. Manual - part 697

 

  Index      Acura     Acura TSX 2004-2008 / Honda Accord CL 2006-2008 - service repair manual

 

Search            copyright infringement  

 

 

 

 

 

 

 

 

 

Content   ..  695  696  697  698   ..

 

 

Acura TSX / Honda Accord CL. Manual - part 697

 

 

disconnect SRS floor harness connector from side impact sensor. Using T30 Torx bit, remove mounting 
screws and side impact sensor. See Fig. 27 .  

2. To install, reverse removal procedure. Tighten side impact sensor mounting screws to specification. See 

TORQUE SPECIFICATIONS . Activate air bag system. See ACTIVATING SYSTEM under 
DISABLING & ACTIVATING AIR BAG SYSTEM.  

Fig. 27: Identifying Side Impact Sensor 
Courtesy of AMERICAN HONDA MOTOR CO., INC. 

SRS UNIT 

Removal & Installation 

1. Before proceeding, see AIR BAG SAFETY PRECAUTIONS . Disable air bag system. See 

DISABLING SYSTEM under DISABLING & ACTIVATING AIR BAG SYSTEM. Disconnect right 
and left seat belt pretensioner connectors. See SEAT BELT PRETENSIONERS .  

2. Remove center console, front panel and cup holder. See CENTER CONSOLE . Remove left and right 

center lower cover and heater ducts. Disconnect SRS unit connectors, remove mounting screws and 
remove SRS unit. See Fig. 28 .  

3. To install, reverse removal procedure. Tighten SRS unit mounting screws to specification. See TORQUE 

SPECIFICATIONS . Activate air bag system. See ACTIVATING SYSTEM under DISABLING & 

 

2004 Acura TSX 

2004 ACCESSORIES/SAFETY EQUIPMENT Acura - Air Bag Restraint Systems

  

 

ACTIVATING AIR BAG SYSTEM. Initialize OPDS system. See INITIALIZING OCCUPANT 
POSITION DETECTION SYSTEM (OPDS) UNIT
 under DIAGNOSTICS.  

Fig. 28: Identifying SRS Unit 
Courtesy of AMERICAN HONDA MOTOR CO., INC. 

ADJUSTMENTS 

CABLE REEL CENTERING 

NOTE:

New replacement cable reels are pre-centered.

 

2004 Acura TSX 

2004 ACCESSORIES/SAFETY EQUIPMENT Acura - Air Bag Restraint Systems

  

 

With cable reel installed, rotate cable reel clockwise until it stops. Rotate cable reel counterclockwise about 3 
turns until arrow mark on cable reel label points straight up. See Fig. 29 . 

Fig. 29: Identifying Cable Reel Arrow Mark 
Courtesy of AMERICAN HONDA MOTOR CO., INC. 

WIRE REPAIR 

DO NOT attempt to modify, splice or repair SRS wiring. If there is an open or damage in SRS wiring or 
terminals, replace harness. 

TORQUE SPECIFICATIONS 

TORQUE SPECIFICATIONS 

NOTE:

SRS wiring can be identified by special Yellow outer protective covering.

Application

Ft. Lbs. (N.m)

Brake pedal support member bolt

12 (16)

 

2004 Acura TSX 

2004 ACCESSORIES/SAFETY EQUIPMENT Acura - Air Bag Restraint Systems

  

 

DIAGNOSTICS 

SELF-DIAGNOSTIC SYSTEM 

SRS includes a self-diagnostic function that checks system for faults in SRS components and related wiring. A 
fault exists if AIR BAG warning light on instrument cluster continues to glow more than 6 seconds after 
ignition is turned on, or glows or flashes while vehicle is driven. 

RETRIEVING DIAGNOSTIC TROUBLE CODE (DTC) 

When AIR BAG warning light is on, read DTC by connecting a HDS tester to 16-pin data link connector, and 
following tester prompts to read directly from HDS tester, or reading AIR BAG warning light flashes. If AIR 
BAG warning light stays on or does not come on, or side air bag cutoff warning light stays on, go to 
DIAGNOSTIC TESTS . 

Seat belt buckle anchor bolt

24 (32)

Seat belt lower anchor bolt

24 (32)

Seat belt pretensioner Lower mounting bolt

24 (32)

Seat belt shoulder anchor bolt

24 (32)

Steering column mounting bolts & nuts

29 (39)

Steering column yoke bolt

21 (28)

Steering wheel bolt

12 (16)

INCH Lbs. (N.m)

Driver-side air bag module Torx bolts

87 (9.8)

Front impact sensor mounting screws

87 (9.8)

Passenger-side air bag mounting bolts & nuts

87 (9.8)

Rear impact sensor mounting screws

87 (9.8)

Seat belt pretensioner upper mounting bolt

87 (9.8)

Side air bag module mounting bolts

56 (6.3)

Side curtain air bag module mounting bolts

87 (9.8)

Side impact sensor mounting screws

87 (9.8)

SRS unit mounting screws

87 (9.8)

Sun visor retaining screws

30 (3.4)

WARNING:

Accidental air bag deployment is possible. Personal injury may result. 
Read and follow all WARNINGS and AIR BAG SAFETY PRECAUTIONS 
before working on air bag system or related components. 
Accidental air bag deployment is possible. Personal injury may result. 
Use only digital multimeter with 10 milliamp or less output rating in 
smallest ohmmeter range.

NOTE:

Ensure battery is sufficiently charged prior to performing diagnostic 
procedures. A dead or low-charged battery may cause inaccurate test values to 
be obtained.

 

2004 Acura TSX 

2004 ACCESSORIES/SAFETY EQUIPMENT Acura - Air Bag Restraint Systems

  

 

 

 

 

 

 

 

 

Content   ..  695  696  697  698   ..