Acura TSX / Honda Accord CL. Manual - part 86

 

  Index      Acura     Acura TSX 2004-2008 / Honda Accord CL 2006-2008 - service repair manual

 

Search            copyright infringement  

 

 

 

 

 

 

 

 

 

Content   ..  84  85  86  87   ..

 

 

Acura TSX / Honda Accord CL. Manual - part 86

 

 

Fig. 23: Removing The Handle From The Holes In The Door Panel 

12. Install the handle in the reverse order of removal, and note these items: 

z

Make sure the key cylinder switch harness is routed properly.  

z

Make sure the key cylinder switch connector is plugged in properly, and each rod is connected 
securely.  

z

Make sure the door key cylinder/door locks operate properly.  

z

Make sure the door handle works properly.  

z

When reinstalling the door panel, make sure the plastic cover is installed properly and sealed 
around its outside perimeter to seal out water.  

FRONT DOOR LATCH REPLACEMENT 

NOTE:

Put on gloves to protect your hands.

 

2004 Acura TSX 

2004 ACCESSORIES & EQUIPMENT Interior Trim - TSX

  

 

1. Raise the glass fully.  

2. Remove these items: 

a. Door panel (see FRONT DOOR PANEL REMOVAL/INSTALLATION )  

b. Plastic cover, as necessary (see COMPONENT LOCATION INDEX )  

c. Center lower channel (see step 4 of FRONT DOOR OUTER HANDLE REPLACEMENT )  

3. Disconnect the outer handle rod from the outer handle, and the cylinder rod from the lock cylinder (see 

step 5 of FRONT DOOR OUTER HANDLE REPLACEMENT ).  

4. Remove the screw securing the lock knob (A). 

 

2004 Acura TSX 

2004 ACCESSORIES & EQUIPMENT Interior Trim - TSX

  

 

Fig. 24: Removing The Screw Securing The Lock Knob

5. Disconnect the actuator connectors (A), and detach the inner handle cable clip (B). Remove the screws 

(C, D) securing the latch (E), and the lock cable protector. 

Fig. 25: Disconnecting The Actuator Connectors & Detaching The Inner Handle Cable Clip 

6. Release the hooks (A) of the lock cable protector (B) from the door, then remove the latch (C) (with the 

protector) through the hole in the door. Take care not to bend the outer handle rod (D), cylinder rod (E), 

 

2004 Acura TSX 

2004 ACCESSORIES & EQUIPMENT Interior Trim - TSX

  

 

lock cable (F), and inner handle cable (G). 

Fig. 26: Removing The Latch 

7. Remove the lock cable protector (A) from the latch protector (B) by releasing the hook (C). 

 

2004 Acura TSX 

2004 ACCESSORIES & EQUIPMENT Interior Trim - TSX

  

 

 

 

 

 

 

 

 

Content   ..  84  85  86  87   ..