Jeep Grand Cherokee WJ. Manual - part 1254

 

  Index      Jeep     Jeep Grand Cherokee WJ - service repair manual 2001 year

 

Search            

 

 

 

 

 

 

 

 

 

Content   ..  1252  1253  1254  1255   ..

 

 

Jeep Grand Cherokee WJ. Manual - part 1254

 

 

Symptom:

*PASSENGER

REAR

WINDOW

INOPERATIVE

FROM

REAR

SWITCH

POSSIBLE CAUSES

OPEN GROUND CIRCUIT

SWITCH DEFECTIVE

TEST

ACTION

APPLICABILITY

1

Note Ensure the Window Lock out Switch on the DDM is operating properly
before proceeding.
Remove the Rear Door Trim Panel.
Disconnect the Power Window Switch connector.
Turn the ignition off.
Turn all lights off.
Measure the resistance of the Ground circuit to ground.
Is the resistance below 5.0 ohms?

All

Yes

Replace the Power Window Switch.
Perform BODY VERIFICATION TEST - VER 1.

No

Repair the open ground circuit.
Perform BODY VERIFICATION TEST - VER 1.

519

POWER WINDOWS

Symptom:

*PASSENGER WINDOW INOPERATIVE FROM BOTH SWITCHES

POSSIBLE CAUSES

PASSENGER DOOR MODULE - OPEN SWITCH

PASSENGER DOOR MODULE - OUTPUT OPEN

PASSENGER MOTOR CIRCUIT CHECK

PASSENGER WINDOW DRIVER DOWN WIRE OPEN

PASSENGER WINDOW DRIVER UP WIRE OPEN

PASSENGER WINDOW DRIVER DOWN SHORTED TO GROUND

PASSENGER WINDOW DRIVER UP SHORTED TO GROUND

PASSENGER WINDOW DRIVER DOWN SHORTED TO VOLTAGE

PASSENGER WINDOW DRIVER UP SHORTED TO VOLTAGE

WINDOW MOTOR OPEN

WINDOW MOTOR SHORT TO GROUND

TEST

ACTION

APPLICABILITY

1

NOTE: Ensure there is communication with the Passenger and Driver Door
Modules before proceeding.
Connect the DRBIII and select:

9Body9 9Door Modules9 9Actuators9

With the DRBIII actuate the

9PASS F WIN UP RLY9 and then the 9PASS F WIN DN

RLY

9..

Did the window operate up and down?

All

Yes

Replace the Passenger Door Module (switch input open)
Perform BODY VERIFICATION TEST - VER 1.

No

Go To

2

2

Disconnect the Passenger Door Module

9C19 connector.

Warning: Keep the window area clear as the window SHOULD move up and
down in this test.
Connect a jumper wire from the Passenger Window Driver Down terminal to the
ground terminal .
Connect a jumper wire from the Passenger Window Driver Up terminal and
momentarily connect it to the Fused B(+) terminal.
Reverse the Jumper wires to run the motor in the oposite direction.
Did the window motor operate up and down?

All

Yes

Replace the Passenger Door Module (output open).
Perform BODY VERIFICATION TEST - VER 1.

No

Go To

3

520

POWER WINDOWS

TEST

ACTION

APPLICABILITY

3

Disconnect the Passenger Door Module

9C19 connector.

Turn ignition off.
Measure and record the total resistance of the motor circuit between the Passenger
Window Driver Up circuit and the Passenger Window Driver Down circuit in the
PDM

9C19 connector (should be under 5.0 ohms).

Measure and record the resistance of the Passenger Window Driver Down circuit to
ground in the PDM

9C19 connector (should be infinite).

Turn ignition on.
Measure and record the voltage of the Passenger Window Driver Down circuit to
ground in the PDM

9C19 connector (should be zero).

What were your readings

All

Total resistance above 5.0 ohms

Go To

4

Resistance to gnd less than 1000 ohms

Go To

7

Voltage above 0.02 volts

Go To

10

None of the above

Check and repair any reasons for the window regulator to bind. If
the mechanism is OK, replace the power window motor.
Perform BODY VERIFICATION TEST - VER 1.

4

Disconnect the Passenger Door Module

9C19 connector.

Disconnect the Passenger Power Window Motor connector.
Measure the resistance of the Passenger Window Driver Down circuit between the
PDM connector and the window motor connector.
Is the resistance below 5.0 ohms?

All

Yes

Go To

5

No

Repair the Passenger Window Driver Down wire for an open.
Perform BODY VERIFICATION TEST - VER 1.

5

Disconnect the Passenger Door Module

9C19 connector.

Disconnect the Passenger Power Window Motor connector.
Measure the resistance of the Passenger Window Driver Up circuit between the PDM
connector and the window motor connector.
Is the resistance below 5.0 ohms?

All

Yes

Go To

6

No

Repair the Passenger Window Driver Up wire for an open.
Perform BODY VERIFICATION TEST - VER 1.

6

If there are no possible causes remaining, view Repair.

All

Repair

Replace the Power Window Motor.
Perform BODY VERIFICATION TEST - VER 1.

521

POWER WINDOWS

*PASSENGER WINDOW INOPERATIVE FROM BOTH SWITCHES —

Continued

TEST

ACTION

APPLICABILITY

7

Disconnect the Passenger Door Module

9C19 connector.

Disconnect the Passenger Power Window Motor connector.
Measure the resistance of the Passenger Window Driver Down circuit to ground.
Is the resistance below 1000.0 ohms?

All

Yes

Repair the Passenger Window Driver Down wire for a short to
ground.
Perform BODY VERIFICATION TEST - VER 1.

No

Go To

8

8

Disconnect the Passenger Door Module

9C19 connector.

Disconnect the Passenger Power Window Motor connector.
Measure the resistance of the Passenger Window Driver Up circuit to ground.
Is the resistance below 1000.0 ohms?

All

Yes

Repair the Passenger Window Driver Up wire for a short to
ground.
Perform BODY VERIFICATION TEST - VER 1.

No

Go To

9

9

If there are no possible causes remaining, view Repair.

All

Repair

Replace the Power Window Motor (internal short)
Perform BODY VERIFICATION TEST - VER 1.

10

Disconnect the Passenger Door Module

9C19 connector.

Disconnect the Passenger Power Window Motor connector.
Measure the voltage of the Passenger Window Driver Down circuit to ground.
Is there ANY voltage on the Passenger Window Driver Down wire?

All

Yes

Repair the Passenger Window Driver Down wire for a short to
voltage.
Perform BODY VERIFICATION TEST - VER 1.

No

Go To

11

11

Disconnect the Passenger Door Module

9C19 connector.

Disconnect the Passenger Power Window Motor connector.
Measure the voltage of the Passenger Window Driver Up circuit to ground.
Is there ANY voltage on the Passenger Window Driver Up wire?

All

Yes

Repair the Passenger Window Driver Up wire for a short to
voltage.
Perform BODY VERIFICATION TEST - VER 1.

No

Test Complete.

522

POWER WINDOWS

*PASSENGER WINDOW INOPERATIVE FROM BOTH SWITCHES —

Continued

 

 

 

 

 

 

 

Content   ..  1252  1253  1254  1255   ..