Jeep Grand Cherokee WJ. Manual - part 1024

 

  Index      Jeep     Jeep Grand Cherokee WJ - service repair manual 2001 year

 

Search            

 

 

 

 

 

 

 

 

 

Content   ..  1022  1023  1024  1025   ..

 

 

Jeep Grand Cherokee WJ. Manual - part 1024

 

 

TEST

ACTION

APPLICABILITY

16

Turn the ignition off.
WARNING: The fuel system is under a constant pressure even with the
engine off. Before testing or servicing any fuel system hose,fitting or line,
the fuel system pressure must be released.
Remove the Fuel Pump Module and inspect the Fuel Inlet Strainer.
Is the Fuel Inlet Strainer plugged?

All

Yes

Replace the Fuel Pump Inlet Strainer.
Perform POWERTRAIN VERIFICATION TEST VER - 1.

No

Test Complete.

313

STARTING

*START AND STALL CONDITION —

Continued

Symptom:

P0711-TRANS TEMP SENSOR, NO TEMP RISE AFTER START

When Monitored and Set Condition:

P0711-TRANS TEMP SENSOR, NO TEMP RISE AFTER START

When Monitored:

Continuously with the key on and the engine running.

Set Condition:

After 2 trips in which the trans sump temp is < 5°C (40° F) and does not

rise more than 8°C (16° F) after 20 minutes of run time with Veh Spd > 48 kmh (30 MPH).
It will also set if the eng temp is < 38°C (100° F) with trans temp > 127°C (260° F).

POSSIBLE CAUSES

MULTIPLE TRANSMISSION DTC’S SET

INTERMITTENT TRANSMISSION TEMPERATURE SENSOR

TRANSMISSION TEMPERATURE SENSOR

TEST

ACTION

APPLICABILITY

1

Turn the ignition on.
With the DRBIII

t, read DTCs.

Is the Good Trip Counter for P0711 displayed and equal to 0?

without 45RFE

AUTO TRANS

Yes

Go To

2

No

Go To

6

2

Turn the ignition on.
With the DRBIII

t, read DTCs.

Check for any Park/Neutral DTCs or Transmission Temperature too Low or too High
DTCs.
Were any Park/Neutral P-1899 or Transmission Temperature Sensor P-0712 or
P0713 codes present?

without 45RFE

AUTO TRANS

Yes

Repair all other transmission DTC’s before proceeding.
Perform TRANSMISSION VERIFICATION TEST VER - 1.

No

Go To

3

3

Turn the ignition on.
Note: To test the transmission temperature sensor, the engine and trans-
mission temperature must be at or below 29.4°C (85° F).
With the DRBIII

t read:

Engine Coolant temperature and record.
Transmission temperature and record.
Is the transmission temperature within 5°C (9°F) of the engine coolant temperature?

without 45RFE

AUTO TRANS

Yes

Go To

4

No

Go To

5

314

TRANSMISSION

TEST

ACTION

APPLICABILITY

4

Note: To test the transmission temperature sensor, the engine and trans-
mission temperature must be at or below 29.4°C (85° F).
Start the engine and let it idle in Drive with parking brake on, while monitoring the
Transmission Temperature Sensor with the DRBIII

t.

Look for the temperature to rise 8°C (15°F) within a ten minute period.
Did the trans temperature increase at a steady rate and rise 8°C (15°F) over a 10
minute period?

without 45RFE

AUTO TRANS

Yes

Go To

6

No

Go To

5

5

Turn ignition off.
Remove the Transmission pan.
Disconnect the Governor Pressure Sensor/Transmission Temperature Sensor connec-
tor.
Note: Check connectors - Clean/repair as necessary
Measure the resistance of the Transmission Temperature Sensor.
Note: Acceptable Sensor Resistance Ranges in OHMS
Sensor Temperature Minimum Maximum
-40°C (-40°F) 1094 1176
0°C (32°F) 1587 1672
25°C (77°F) 1960 2040
70°C (158°F) 2709 2860
100°C (212°F) 3284 3500
120°C (120°F) 3684 3950
150°C (302°F) 4110 4450
Is the resistance within the specified range when the sensor is at the given
temperature?

without 45RFE

AUTO TRANS

Yes

Test Complete.

No

Replace the Governor Pressure/Transmission Temperature Sen-
sor in accordance with the Service Information.
Perform TRANSMISSION VERIFICATION TEST VER - 1.

6

At this time, the conditions required to set the DTC are not present.
Note: Use the Freeze Frame Data to help duplicate the conditions that set
the DTC. Pay particular attention to the DTC set conditions, such as, VSS,
MAP, ECT, and Load.
Note: Visually inspect the related wiring harness. Look for any chafed,
pierced, pinched, or partially broken wires.
Note: Visually inspect the related wiring harness connectors. Look for
broken, bent, pushed out, or corroded terminals.
NOTE: Refer to any Technical Service Bulletins that may apply.
Were any problems found?

without 45RFE

AUTO TRANS

Yes

Repair as necessary.
Perform TRANSMISSION VERIFICATION TEST VER - 1.

No

Test Complete.

315

TRANSMISSION

P0711-TRANS TEMP SENSOR, NO TEMP RISE AFTER START —

Continued

Symptom:

P0712-TRANS TEMP SENSOR VOLTAGE TOO LOW

When Monitored and Set Condition:

P0712-TRANS TEMP SENSOR VOLTAGE TOO LOW

When Monitored:

Continuously with the key on and the engine running.

Set Condition:

This code will set if the Transmission Temperature Sensor Signal circuit

voltage goes below 1.55 volts for 2.2 seconds.

POSSIBLE CAUSES

5-VOLT SUPPLY CIRCUIT SHORTED TO GROUND

INTERMITTENT TRANSMISSION TEMPERATURE SENSOR

5-VOLT SUPPLY CIRCUIT SHORTED TO THE SENSOR GROUND CIRCUIT

TRANS TEMP SENSOR SIGNAL CIRCUIT SHORTED TO GROUND

TRANS TEMP SENSOR SIGNAL CIRCUIT SHORTED TO THE SENSOR GROUND CIRCUIT

5-VOLT SUPPLY CIRCUIT SHORTED TO GROUND INSIDE TRANS

5-VOLT SUPPLY CIRCUIT SHORTED TO THE SENSOR GROUND CIRCUIT INSIDE TRANS

TRANS TEMP SENSOR SIGNAL CIRCUIT SHORTED TO GROUND INSIDE TRANS

TRANS TEMP SENSOR SIGNAL CKT SHORTED TO THE SENSOR GROUND CKT INSIDE
TRANS

TRANSMISSION TEMPERATURE SENSOR

POWERTRAIN CONTROL MODULE

TEST

ACTION

APPLICABILITY

1

Turn the ignition on.
With the DRB, read DTCs.
Is the Specific Good Trip Counter for P0712 displayed and equal to 0?

without 45RFE

AUTO TRANS

Yes

Go To

2

No

Go To

12

2

Turn the ignition off.
Disconnect the PCM harness connectors.
Disconnect the Transmission Solenoid Assembly harness connector.
Check connectors - Clean/repair as necessary
Measure the resistance between ground and the 5-volt Supply circuit in the
Transmission Solenoid Assembly harness connector.
Is the resistance above 100 kohms?

without 45RFE

AUTO TRANS

Yes

Go To

3

No

Repair the 5-volt Supply circuit for a short to ground.
Perform TRANSMISSION VERIFICATION TEST VER - 1.

316

TRANSMISSION

 

 

 

 

 

 

 

Content   ..  1022  1023  1024  1025   ..