Jeep Grand Cherokee WJ. Manual - part 59

 

  Index      Jeep     Jeep Grand Cherokee WJ - service repair manual 2001 year

 

Search            

 

 

 

 

 

 

 

 

 

Content   ..  57  58  59  60   ..

 

 

Jeep Grand Cherokee WJ. Manual - part 59

 

 

(6) Feed sensor wires through floorpan access hole

and seat sensor grommets in floorpan.

(7) Remove support and lower the vehicle.
(8) Fold rear seat and carpet forward for access to

sensor wires and connectors.

(9) Connect sensor wires to harness connectors.
(10) Reposition carpet and fold rear seat down.

G-SWITCH

REMOVAL

(1) Fold the rear seat bottom assembly up for

access to the switch.

(2) Lift up the carpeting and disconnect switch

harness (Fig. 13).

(3) Remove the switch mounting bolts and remove

the switch.

INSTALLATION

CAUTION: The

mercury

switch

(inside

the

G-Switch), will not function properly if the switch is
installed incorrectly. Verify that the switch locating
arrow is pointing to the front of the vehicle (Fig.
14).

Fig. 11 Sensor Mounting Bolt

1 – WHEEL SPEED SENSOR
2 – MOUNTING BOLT

Fig. 12 Wheel Speed Sensor

1 – WHEEL SPEED SENSOR
2 – BACKING PLATE

Fig. 13 G-Switch Mounting

1 – MOUNTING BOLTS
2 – CONNECTOR
3 – G-SWITCH

Fig. 14 G-Switch

1 – SWITCH PART NUMBER
2 – ARROW INDICATES FRONT OF SWITCH FOR PROPER

MOUNTING

5 - 44

BRAKES

WJ

REMOVAL AND INSTALLATION (Continued)

(1) Note position of locating arrow on switch. Posi-

tion switch so arrow faces forward.

(2) Install the switch and tighten mounting bolts

to 5.6 N·m (50 in. lbs.).

(3) Connect harness to switch. Be sure harness

connector is firmly seated.

(4) Place the carpet in position and fold the rear

seat back down.

SPECIFICATIONS

TORQUE CHART

DESCRIPTION

TORQUE

G-Sensor

Sensor Bolt . . . . . . . . . . . . . . 5.6 N·m (50 in. lbs.)

Hydraulic Control Unit/Controller Antilock

Brakes

Mounting Bolts . . . . . . . . . . . . 12 N·m (9 ft. lbs.)
Brake Lines . . . . . . . . . . . . . 16 N·m (144 in. lbs.)
CAB Screws . . . . . . . . . . . . . 1.8 N·m (16 in. lbs.)

Wheel Speed Sensors

Front Sensor Bolt . . 12-14 N·m (106-124 in. lbs.)
Rear Sensor Bolt . . . 12-14 N·m (106-124 in. lbs.)

WJ

BRAKES

5 - 45

REMOVAL AND INSTALLATION (Continued)

COOLING SYSTEM

TABLE OF CONTENTS

page

page

DESCRIPTION AND OPERATION

COOLING SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . 2
SYSTEM COOLANT ROUTING . . . . . . . . . . . . . . . 2
WATER PUMP BYPASS—4.7L . . . . . . . . . . . . . . . 3
AUTOMATIC TRANSMISSION OIL COOLER. . . . . 4
COOLANT RESERVOIR / OVERFLOW

SYSTEM. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

ENGINE BLOCK HEATER . . . . . . . . . . . . . . . . . . . 4
RADIATOR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
THERMOSTAT . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
RADIATOR PRESSURE CAP . . . . . . . . . . . . . . . . . 6
COOLING SYSTEM HOSES AND HOSE

CLAMPS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

WATER PUMP . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
VISCOUS FAN DRIVE . . . . . . . . . . . . . . . . . . . . . . 8

DIAGNOSIS AND TESTING

ON-BOARD DIAGNOSTICS (OBD) . . . . . . . . . . . . 9
DRB SCAN TOOL . . . . . . . . . . . . . . . . . . . . . . . . 10
WATER PUMP TESTS. . . . . . . . . . . . . . . . . . . . . 10
SERPENTINE DRIVE BELT DIAGNOSIS . . . . . . . 11
THERMOSTAT . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
COOLING SYSTEM DIAGNOSIS . . . . . . . . . . . . . 13
PRELIMINARY CHECKS . . . . . . . . . . . . . . . . . . . 13
COOLING SYSTEM—TESTING FOR LEAKS . . . . 20
RADIATOR COOLANT FLOW CHECK . . . . . . . . . 20
VISCOUS FAN DRIVE . . . . . . . . . . . . . . . . . . . . . 21
ELECTRIC COOLING FAN . . . . . . . . . . . . . . . . . . 22
RADIATOR CAP TO FILLER NECK

SEAL—PRESSURE RELIEF CHECK . . . . . . . . . 22

RADIATOR CAP—PRESSURE TESTING. . . . . . . 22
DEAERATION . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
ENGINE BLOCK HEATER . . . . . . . . . . . . . . . . . . 23
LOW COOLANT LEVEL-AERATION . . . . . . . . . . . 23

SERVICE PROCEDURES

COOLANT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24
COOLANT LEVEL—ROUTINE CHECK. . . . . . . . . 24
COOLANT SELECTION AND ADDITIVES . . . . . . 24
COOLANT—ADDING ADDITIONAL. . . . . . . . . . . 24
DRAINING AND FILLING COOLING SYSTEM. . . 25
SERVICE COOLANT LEVEL. . . . . . . . . . . . . . . . . 25
COOLING SYSTEM—REVERSE FLUSHING . . . . 26

REMOVAL AND INSTALLATION

WATER PUMP—4.0L ENGINE . . . . . . . . . . . . . . 27
WATER PUMP 4.7L ENGINES . . . . . . . . . . . . . . 29
THERMOSTAT—4.0L ENGINE . . . . . . . . . . . . . . 31
THERMOSTAT— 4.7L ENGINE . . . . . . . . . . . . . . 32
RADIATOR FAN SHROUD . . . . . . . . . . . . . . . . . . 33
RADIATOR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 34
WATER PUMP BYPASS HOSE—4.0L ENGINE. . 37
ENGINE BLOCK HEATER . . . . . . . . . . . . . . . . . . 38
BELT REPLACEMENT/ADJUSTMENT . . . . . . . . . 39
AUTOMATIC BELT TENSIONER . . . . . . . . . . . . . 41
COOLING SYSTEM FAN 4.0L AND 4.7L

ENGINES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42

VISCOUS FAN DRIVE . . . . . . . . . . . . . . . . . . . . . 43

CLEANING AND INSPECTION

FAN BLADE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 43
RADIATOR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 43
RADIATOR PRESSURE CAP . . . . . . . . . . . . . . . . 43
WATER PUMP . . . . . . . . . . . . . . . . . . . . . . . . . . 43
COOLING SYSTEM HOSES. . . . . . . . . . . . . . . . . 44

SPECIFICATIONS

COOLING SYSTEM CAPACITIES. . . . . . . . . . . . . 44
DRIVE BELT TENSION . . . . . . . . . . . . . . . . . . . . 44
INFORMATION . . . . . . . . . . . . . . . . . . . . . . . . . . 44
TORQUE SPECIFICATIONS . . . . . . . . . . . . . . . . . 44

SPECIAL TOOLS

COOLING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 45

WJ

COOLING SYSTEM

7 - 1

 

 

 

 

 

 

 

Content   ..  57  58  59  60   ..