Honda Odyssey 2004. Manual - part 16

 

  Index      Honda     Honda Odyssey 2004 - service repair manual 2004 year

 

Search            

 

 

 

 

 

 

 

 

 

Content   ..  14  15  16  17   ..

 

 

Honda Odyssey 2004. Manual - part 16

 

 

2001 Model

Part

Maintenance Items

3-12

Maintenance Schedule

Listed by Distance/Time for Normal Conditions (cont’d)

This two-page Maintenance Schedule outlines the minimum required maintenance. Service at the indicated distance
or time, whichever comes first. Use the Maintenance Schedule for Severe Conditions if the vehicle meets any of the
qualifiers in the Severe Conditions schedule or if the vehicle is normally driven in Canada.

Do the items in parts A, B, C, D, E, and F as required for the mileage/time interval listed.

C

Replace air cleaner element (see page 11-240), every 30,000 miles (48,000 km).
Inspect and adjust drive belts, every 30,000 miles (48,000 km) or 2 years.

Look for cracks and damage, then check belt deflection by pushing on the belt about 98 N (10 kgf, 22
lbf) midway between the pulleys.
P/S pump belt: 13.0

16.5 mm (1/2

Replace dust and pollen filter (see page 21-44), every 30,000 miles (48,000 km) or 2 years.

Replace the filter as often (at 15,000 miles/24,000 km intervals) if the vehicle is driven mostly in urban
areas that have high concentrations of soot in the air from industry and diesel-powered vehicles.
Replace the filter whenever airflow from the heating and cooling/climate control system is less than
normal.

D

Replace transmission fluid (see page 14-137), at 45,000 miles (72,000 km) or 3 years, then every 30,000
miles (48,000 km) or 2 years.

Capacity: 2.9

(3.1 US qt), use Honda ATF-Z1.

E

Inspect the valve clearance, otherwise adjust only if noisy (see page 6-15), every 105,000 miles (168,000
km) or 7 years.

Intake: 0.20

0.24 mm (0.008

0.009 in.), Exhaust: 0.28

0.32 mm (0.011

0.013 in.).

Replace spark plugs (see page 4-18), every 105,000 miles (168,000 km) or 7 years.

GAP: 1.0

1.1 mm (0.039

0.043 in.), use PZFR5F11 (NGK) or PKJ16CR-L11 (DENSO).

Replace timing belt (see page 6-20), and inspect water pump (see page 10-12), every 105,000 miles
(168,000 km) or 7 years.

F

Replace engine coolant (see page 10-13), at 120,000 miles (192,000 km) or 10 years, then every 60,000
miles (96,000 km) or 5 years.

Use Honda All Season Antifreeze/coolant Type 2.

NOTE: According state and federal regulations, failure to do the maintenance items marked with an asterisk (

) will

not void the customer’s emissions warranties. However, Honda recommends that all maintenance services be done at
the recommended intervals to ensure long-term reliability.

03/07/29 09:06:15 61S0X050_030_0012

5/8 in.) (see page 17-13).

―――
―――
―――

―――
―――
―――

―――
―――
―――

―――

―――

―――
―――
―――

―――
―――
―――

―――
―――
―――

―――

―――

―――
―――
―――

±

―――
―――
―――

―――

―――

S0X4AZ1000000000000JAAT24

2001 Model

Severe Driving Conditions

Distance

Time

Maintenance Items

3-13

Listed by Distance/Time for Severe Conditions

Use the Severe Conditions schedule if the vehicle is driven MAINLY in Canada or in any of the following conditions; if only OCCASIONALLY
driven in these conditions, use the Normal Conditions schedule.





Driving less than 5 miles (8 km) per trip or, in freezing temperatures, driving less than 10 miles (16 km) per trip.
Driving in extremely hot over 90°F (32°C) conditions.
Extensive idling, or long periods of stop-and-go driving, such as a taxi or a commercial delivery vehicle.
Trailer towing, driving with a roof rack, or driving in mountainous conditions.
Driving on muddy, dusty, or de-iced roads.

3,750 miles

6,000 km

Do items in A.

7,500 miles

12,000 km

Do items in A and B.

11,250 miles

18,000 km

Do items in A.

15,000 miles

24,000 km

1 year

Do items in A, B, C, and D.

18,750 miles

30,000 km

Do items in A.

22,500 miles

36,000 km

Do items in A and B.

26,250 miles

42,000 km

Do items in A.

30,000 miles

48,000 km

2 years

Do items in A, B, C, and E.

33,750 miles

54,000 km

Do items in A.

37,500 miles

60,000 km

Do items in A and B.

41,250 miles

66,000 km

Do items in A.

45,000 miles

72,000 km

3 years

Do items in A, B, C, and D.

3 years

Replace brake fluid (see page 19-9).

48,750 miles

78,000 km

Do items in A.

52,500 miles

84,000 km

Do items in A and B.

56,250 miles

90,000 km

Do items in A.

60,000 miles

96,000 km

4 years

Do items in A, B, C, E, and F.

63,750 miles

102,000 km

Do items in A.

67,500 miles

108,000 km

Do items in A and B.

71,250 miles

114,000 km

Do items in A.

75,000 miles

120,000 km

5 years

Do items in A, B, C, and D.

78,750 miles

126,000 km

Do items in A.

82,500 miles

132,000 km

Do items in A and B.

86,250 miles

138,000 km

Do items in A.

90,000 miles

144,000 km

6 years

Do items in A, B, C, and E.

6 years

93,750 miles

150,000 km

Do items in A.

97,500 miles

156,000 km

Do items in A and B.

101,250 miles

162,000 km

Do items in A.

105,000 miles

168,000 km

7 years

Do items in A, B, C, D, F, and G.
Inspect idle speed (see page 11-201).

Idle speed: 730

50 rpm in N or P position.

108,750 miles

174,000 km

Do items in A.

112,500 miles

180,000 km

Do items in A and B.

116,250 miles

186,000 km

Do items in A.

120,000 miles

192,000 km

8 years

Do items in A, B, C, E, and F.

9 years

Replace brake fluid (see page 19-9).

120,000 miles

192,000 km

10 years

Do item in H.

(cont’d)

03/07/29 09:06:15 61S0X050_030_0013

Replace brake fluid (see page 19-9).

2001 Model

Severe Driving Conditions

Part

Maintenance Items

3-14

Maintenance Schedule

Listed by Distance/Time for Severe Conditions (cont’d)

Use the Severe Conditions schedule if the vehicle is driven MAINLY in Canada or in any of the following conditions; if only OCCASIONALLY
driven in these conditions, use the Normal Conditions schedule.





Driving less than 5 miles (8 km) per trip or, in freezing temperatures, driving less than 10 miles (16 km) per trip.
Driving in extremely hot over 90°F (32°C) conditions.
Extensive idling, or long periods of stop-and-go driving, such as a taxi or a commercial delivery vehicle.
Trailer towing, driving with a roof rack, or driving in mountainous conditions.
Driving on muddy, dusty, or de-iced roads.

Do the items in parts A, B, C, D, E, F, G, and H as required for the mileage/time interval listed.

A

Replace engine oil (see page 8-5).

Capacity: without oil filter 4.0

(4.2 US qt), every 3,750 miles (6,000 km) or 6 months.

Replace engine oil filter (see page 8-5).

Capacity: with oil filter 4.4

(4.6 US qt), every 3,750 miles (6,000 km) or 6 months.







B

Check front and rear brakes (see page 19-12), every 7,500 miles (12,000 km) or 6 months.

Check pads and discs for wear (thickness), damage, and cracks.
Check calipers for damage, leaks, and tightness of mount bolts.
Check wheel cylinders for leaks.
Check brake linings for cracking, glazing, wear, or contamination.

Rotate tires, and check tire inflation and condition, every 7,500 miles (12,000 km).

Follow the pattern shown in the Owner’s Manual.

Inspect tie rod ends, steering gearbox, and gearbox boot (see page 17-3), every 7,500 miles (12,000 km) or 6 months.

Check rack grease and steering linkage.
Check boots for damage and leaking grease.
Check fluid lines for damage and leaks.

Inspect suspension components (see page 18-3), every 7,500 miles (12,000 km) or 6 months.

Check bolts for tightness.
Check condition of ball joint boots for deterioration and damage.

Inspect driveshaft boots (see page 16-3), every 7,500 miles (12,000 km) or 6 months.






C

Check parking brake adjustment (see page 19-7), every 15,000 miles (24,000 km) or 1 year.

Number of clicks (3 to 5) when parking brake pedal is pressed with 294 N (30 kgf, 66 lbf) of force.

Lubricate all hinges, locks, and latches, every 15,000 miles (24,000 km) or 1 year.

With Honda White Lithum grease.

Inspect brake hoses and lines including ABS (see page 19-35), every 15,000 miles (24,000 km) or 1 year.

Check the master cylinder, proportioning contorol valve, and ABS modulator for damage and leakage (see page 19-35).

Inspect all fluid levels and condition of fluids, every 15,000 miles (24,000 km) or 1 year.

Automatic transmission fluid (ATF-Z1) (see page 14-136).
Power steering fluid (see page 17-14).
Brake fluid (see page 19-9).
Windshield washer fluid.
Engine coolant (see page 10-13).

Inspect cooling system hoses and connections (see page 10-2), every 15,000 miles (24,000 km) or 1 year.

Check for damage, leaks, and deterioration.
Check for proper fan operation.

Inspect exhaust system (see page 9-10) , every 15,000 miles (24,000 km) or 1 year.

Check catalytic converter heat shield, exhaust pipe, and muffler for damage, leaks, and tightness.

Inspect fuel lines and connections (see page 11-219) , every 15,000 miles (24,000 km) or 1 year.

Check for loose connections, cracks, and deterioration; retighten loose connections and replace damaged parts.

Check lights and controls, every 15,000 miles (24,000 km) or 1 year.

Check function of interior and exterior lights and position of the headlights (see page 22-130).

Inspect vehicle underbody, every 15,000 miles (24,000 km) or 1 year.

Check the paint for damage, scratches, stone chipping, and dents.

NOTE: According state and federal regulations, failure to do the maintenance items marked with an asterisk (

) will not void the customer’s

emissions warranties. However, Honda recommends that all maintenance services be done at the recommended intervals to ensure long-term
reliability.

03/07/29 09:06:15 61S0X050_030_0014

Part

Maintenance Items

3-15

Do the items in parts A, B, C, D, E, F, G, and H as required for the mileage/time interval listed.

D

Clean air cleaner element with low pressure air (see page 11-240), every 15,000 miles (24,000 km).

E

Replace air cleaner element (see page 11-240), every 30,000 miles (48,000 km).
Inspect and adjust drive belts, every 30,000 miles (48,000 km) or 2 years.

Look for cracks and damage, then check belt deflection by pushing on the belt about 98 N (10 kgf, 22 lbf) midway between the
pulleys.
P/S pump belt: 13.0

16.5 mm (1/2

Replace dust and pollen filter (see page 21-44), every 30,000 miles (48,000 km) or 2 years.

Replace the filter as often (at 15,000 miles/24,000 km intervals) if the vehicle is driven mostly in urban areas that have high
concentrations of soot in the air from industry and diesel-powered vehicles.
Replace the filter whenever airflow from the heating and cooling/climate control system is less than normal.

Replace transmission fluid (see page 14-137), every 30,000 miles (48,000 km) or 2 years.

Capacity: 2.9

(3.1 US qt), use Honda ATF-Z1.

F

Replace timing belt (see page 6-20), and inspect water pump (see page 10-12), every 105,000 miles (168,000 km) or 7 years.

G

Inspect the valve clearance, otherwise adjust only if noisy (see page 6-15), every 105,000 miles (168,000 km).

Intake: 0.20

0.24 mm (0.008

0.009 in.), Exhaust: 0.28

0.32 mm (0.011

0.013 in.).

Replace spark plugs (see page 4-18), every 105,000 miles (168,000 km).

GAP: 1.0

1.1 mm (0.039

0.043 in.), use PZFR5F11 (NGK) or PKJ16CR-L11 (DENSO).

H

Replace engine coolant (see page 10-13), at 45,000 miles (72,000 km) or 3 years, then every 30,000 miles (48,000 km) or 2 years.

Use Honda All Season Antifreeze/coolant Type 2.

NOTE: According state and federal regulations, failure to do the maintenance items marked with an asterisk (

) will not void the customer’s

emissions warranties. However, Honda recommends that all maintenance services be done at the recommended intervals to ensure long-term
reliability.

03/07/29 09:06:16 61S0X050_030_0015

5/8 in.) (see page 17-13).

 

 

 

 

 

 

 

Content   ..  14  15  16  17   ..